Standard Test Method for Thermal Conductivity of Refractories

SIGNIFICANCE AND USE
The thermal conductivity of refractories is a property required for selecting their thermal transmission characteristics. Users select refractories to provide specified conditions of heat loss and cold face temperature, without exceeding the temperature limitation of the refractory. This test method establishes the testing for thermal conductivity of refractories using the calorimeter.
This procedure requires a large thermal gradient and steady state conditions. The results are based upon a mean temperature.  
The data from this test method are suitable for specification acceptance, and design of multi-layer refractory construction.  
The use of these data requires consideration of the actual application environment and conditions.
SCOPE
1.1 This test method covers the determination of the comparative thermal conductivity of refractories under standardized conditions of testing. This test method is designed for refractories having a conductivity factor of not more than 200 Btu·in./h·ft2·°F (2818 W/m·K), for a thickness of 1 in. (25 mm).  
1.2 Detailed ASTM test methods to be used in conjunction with this procedure in testing specific types of refractory materials are as follows: Test Method C 182, Test Method C 202, Test Method C 417, and Test Method C 767.  
1.3 The values stated in inch-pound units are to be regarded as standard. The values given in parentheses are mathematical conversions to SI units that are provided for information only and are not considered standard.
1.4 This standard does not purport to address all of the safety concerns, if any, associated with its use. It is the responsibility of the user of this standard to establish appropriate safety and health practices and determine the applicability of regulatory limitations prior to use.

General Information

Status
Historical
Publication Date
28-Feb-2009
Technical Committee
Drafting Committee
Current Stage
Ref Project

Relations

Buy Standard

Standard
ASTM C201-93(2009) - Standard Test Method for Thermal Conductivity of Refractories
English language
6 pages
sale 15% off
Preview
sale 15% off
Preview

Standards Content (Sample)


NOTICE: This standard has either been superseded and replaced by a new version or withdrawn.
Contact ASTM International (www.astm.org) for the latest information
Designation: C201 − 93(Reapproved 2009)
Standard Test Method for
Thermal Conductivity of Refractories
This standard is issued under the fixed designation C201; the number immediately following the designation indicates the year of
original adoption or, in the case of revision, the year of last revision.Anumber in parentheses indicates the year of last reapproval.A
superscript epsilon (´) indicates an editorial change since the last revision or reapproval.
1. Scope E220Test Method for Calibration of Thermocouples By
Comparison Techniques
1.1 This test method covers the determination of the com-
parative thermal conductivity of refractories under standard-
3. Significance and Use
ized conditions of testing. This test method is designed for
3.1 The thermal conductivity of refractories is a property
refractories having a conductivity factor of not more than 200
required for selecting their thermal transmission characteris-
Btu·in./h·ft ·°F(2818W/m·K),forathicknessof1in.(25mm).
tics.Usersselectrefractoriestoprovidespecifiedconditionsof
1.2 Detailed ASTM test methods to be used in conjunction
heat loss and cold face temperature, without exceeding the
with this procedure in testing specific types of refractory
temperature limitation of the refractory. This test method
materials are as follows: Test Method C182, Test Method
establishes the testing for thermal conductivity of refractories
C202, Test Method C417, and Test Method C767.
using the calorimeter.
1.3 The values stated in inch-pound units are to be regarded
3.2 This procedure requires a large thermal gradient and
as standard. The values given in parentheses are mathematical
steady state conditions. The results are based upon a mean
conversions to SI units that are provided for information only
temperature.
and are not considered standard.
3.3 The data from this test method are suitable for specifi-
1.4 This standard does not purport to address all of the
cation acceptance, and design of multi-layer refractory con-
safety concerns, if any, associated with its use. It is the
struction.
responsibility of the user of this standard to establish appro-
3.4 Theuseofthesedatarequiresconsiderationoftheactual
priate safety and health practices and determine the applica-
application environment and conditions.
bility of regulatory limitations prior to use.
4. Apparatus
2. Referenced Documents
4.1 The apparatus shall conform in close detail with that
2.1 ASTM Standards:
shown in the approved drawings. The equipment is shown in
C134Test Methods for Size, Dimensional Measurements,
Fig. 1 and Fig. 2, and the essential parts are as follows:
and Bulk Density of Refractory Brick and Insulating
4.1.1 Heating Chamber—Aheating chamber, shown in Fig.
Firebrick
3, shall be capable of being heated electrically over a tempera-
C155Classification of Insulating Firebrick
ture range from 400 to 2800°F (205 to 1540°C) in a neutral or
C182Test Method for Thermal Conductivity of Insulating
oxidizingatmosphere.Thetemperatureoftheheatingunitshall
Firebrick
be controlled by a mechanism capable of maintaining the
C202Test Method for Thermal Conductivity of Refractory
temperatureinthechamberconstanttowithin 65°F(63°C).A
Brick
siliconcarbideslab13 ⁄2by9by1in.(342by228by25mm),
C417Test Method for Thermal Conductivity of Unfired
with the 13 ⁄2 by 9-in. (342 by 228 mm) faces plane and
Monolithic Refractories
parallel, shall be placed above the sample for the purpose of
C767Test Method for Thermal Conductivity of Carbon
providing uniform heat distribution. A layer of insulation
Refractories
equivalent at least to 1 in. (25 mm) of Group 20 insulating
1 firebrick (see Classification C155) shall be placed below the
This test method is under the jurisdiction of ASTM Committee C08 on
Refractories and is the direct responsibility of Subcommittee C08.02 on Thermal
calorimeter and guard plates.
Properties.
Current edition approved March 1, 2009. Published April 2009. Originally
approved in 1945. Last previous edition approved in 2004 as C201–93 (2004). The complete set of approved drawings necessary for the construction of the
DOI: 10.1520/C0201-93R09. apparatus and suggested operating instructions, each of which requires too much
For referenced ASTM standards, visit the ASTM website, www.astm.org, or space to be included with this test method, were originally drafted by the Insulating
contact ASTM Customer Service at service@astm.org. For Annual Book of ASTM Products Division of Babcock and Wilcox Co. ASTM has been advised that these
Standards volume information, refer to the standard’s Document Summary page on drawings are no longer available. Subcommittee C08.05 currently is taking this
the ASTM website. issue under advisement.
Copyright © ASTM International, 100 Barr Harbor Drive, PO Box C700, West Conshohocken, PA 19428-2959. United States
C201 − 93 (2009)
4.1.4 Instruments for Measuring Temperature of Specimen
—Calibrated thermocouples shall be embedded in the test
specimen for measuring the temperature. The electromotive
force (emf) for the temperature readings shall be taken with a
potentiometer having an instrument error of not more than
60.05 mV, and the cold junctions of the thermocouples shall
be immersed in a mixture of ice and water.
4.1.5 Instrument for Measuring Temperature Rise in Calo-
rimeter Water—A multiple differential thermocouple shall be
used for measuring within an accuracy of not less than 1% of
the temperature rise of the water flowing through the calorim-
eter. The thermocouple shall be immersed at least 3 ⁄2 in. (89
mm)intheinletandoutletconnections,andthejunctionsshall
be not more than ⁄4 in. (6 mm) distant from the bottom of the
calorimeter. A calibrated differential 10X copper-constantan
thermocouple shall be used, and the millivolt readings shall be
taken with a potentiometer having an instrument error of not
more than 60.01 mV in the range between 0 and 2 mV.
4.1.6 Instruments for Measuring Temperature Difference
BetweenCalorimeterandInnerGuard—Calibrateddifferential
10X copper-constantan thermocouples shall be located in the
calorimeter and inner guard for measuring the temperature
differences between the calorimeter and inner guard. The
temperature difference during a test shall be maintained at a
value less than 60.05°F (60.03°C). The thermocouple junc-
tions shall be placed in the four wells provided for that
purpose, and millivolt readings shall be taken with a potenti-
ometerhavinganinstrumenterrorofnotmorethan 60.01mV
in the range between 0 and 2 mV.
NOTE 1—The upper half of the heating chamber has been raised to
permit introduction of the test samples.
5. Test Sample and Its Preparation
FIG. 1 Photograph of Thermal Conductivity Apparatus
5.1 TestSample—Thetestsampleshallconsistofthree9-in.
1 1
(228-mm)straightbrickandsix9by2 ⁄2by2 ⁄4-in.(228by64
4.1.2 Calorimeter Assembly—A copper calorimeter assem-
by 57-mm) soap brick (Note 2) that are representative of the
bly, of the design shown in Fig. 4, shall be used for measuring
material being tested. These brick shall be selected for unifor-
the quantity of heat flowing through the test specimen. The
mity of structure and bulk density, and they shall be free of
water circulation is such that adjacent passages contain incom-
broken corners or edges. One brick shall be used as the test
ing and outgoing streams of water. The calorimeter shall be 3
specimen, and one each of the other two brick shall be used as
by3in.(76by76mm)squareandshallhaveoneinletandone
guard brick on either side of the specimen. The six soap brick
outlet water connection. The inner guard surrounding the
shallbeplacedaroundtheedgesofthetestspecimenandguard
calorimeter shall be 13 ⁄2 by 9 in. (342 by 228 mm) and shall
bricktopreventsideflowofheat.Thetestspecimenandguard
have two inlet and two outlet water connections. The outer
brick shall cover an area of approximately 18 by 13 ⁄2 in. (456
guardshallextend2in.(51mm)laterallyfromtheinnerguard
by 342 mm).
and shall extend vertically to the member comprising the
NOTE 1—A total of nine 9-in. (228-mm) straight brick may be
bottom of the heating chamber (see Fig. 3). The separation
1 submitted for test, six of which would be cut to obtain the soap brick.
betweenthecalorimeterandtheinnerguardshallbe ⁄32in.(0.8
mm). 5.2 Preparation of Test Sample—The9by4 ⁄2-in. (228 by
4.1.3 Water-Circulating
...

Questions, Comments and Discussion

Ask us and Technical Secretary will try to provide an answer. You can facilitate discussion about the standard in here.