EN 60335-2-40:2003
(Main)Household and similar electrical appliances - Safety - Part 2-40: Particular requirements for electrical heat pumps, air-conditioners and dehumidifiers
Household and similar electrical appliances - Safety - Part 2-40: Particular requirements for electrical heat pumps, air-conditioners and dehumidifiers
Deals with the safety of electric heat pumps, including sanitary hot water heat pumps, air-conditioners, and dehumidifiers incorporating sealed motor-compressors. The maximum rated voltage being not more than 250 V for single phase and 600 V for all other appliances. The referenced appliances may consist of one or more assemblies. If provided in more than one assembly, the assemblies are to used together, and the requirements are based on the use of matched assemblies. Supplementary heaters, or a provision for their seperate installation, are within the scope of this standard, but only heaters which are designed as a part of the appliance package, the controls being incorporated in the appliance.
Sicherheit elektrischer Geräte für den Hausgebrauch und ähnliche Zwecke - Teil 2-40: Besondere Anforderungen für elektrisch betriebene Wärmepumpen, Klimageräte und Raumluft-Entfeuchter
Appareils électrodomestiques et analogues - Sécurité - Partie 2-40: Règles particulières pour les pompes à chaleur électriques, les climatiseurs et les déshumidificateurs
Gospodinjski in podobni električni aparati - Varnost - 2-40. del: Posebne zahteve za električne toplotne črpalke, klimatske naprave in sušilnike zraka (IEC 60335-2-40:2002; spremenjen) (vsebuje popravek AC:2006)
Ta standard obravnava varnost električnih toplotnih črpalk, vključno s toplotnimi črpalkami za gospodinjsko vročo vodo, klimatskimi napravami in sušilniki zraka z zaprtimi gnanimi kompresorji. Najvišja nazivna napetost ne sme presegati 250 V za enofazne naprave in 600 V za vse druge naprave. Navedene naprave so lahko sestavljene iz enega sestava ali več. Če zajemajo več kot en sestav, se morajo sestavi uporabljati skupaj, zahteve pa temeljijo na uporabi združenih sestavov. Dodaten grelnik ali ukrepi za njihovo ločeno namestitev spadajo v področje uporabe tega standarda, vendar to velja le za grelnike, ki so zasnovani kot del naprave, pri čemer so kontrole vgrajene v napravo.
General Information
Relations
Standards Content (Sample)
SLOVENSKI STANDARD
01-december-2003
1DGRPHãþD
SIST EN 60335-2-40:1998
SIST EN 60335-2-40:1998/A1:2001
SIST EN 60335-2-40:1998/A11:2005
*RVSRGLQMVNLLQSRGREQLHOHNWULþQLDSDUDWL9DUQRVWGHO 3RVHEQH]DKWHYH
]DHOHNWULþQHWRSORWQHþUSDONHNOLPDWVNHQDSUDYHLQVXãLOQLNH]UDND ,(&
VSUHPHQMHQ YVHEXMHSRSUDYHN$&
Household and similar electrical appliances - Safety -- Part 2-40: Particular requirements
for electrical heat pumps, air-conditioners and dehumidifiers
Sicherheit elektrischer Geräte für den Hausgebrauch und ähnliche Zwecke -- Teil 2-40:
Besondere Anforderungen für elektrisch betriebene Wärmepumpen, Klimageräte und
Raumluft-Entfeuchter
Appareils électrodomestiques et analogues - Sécurité -- Partie 2-40: Règles particulières
pour les pompes à chaleur électriques, les climatiseurs et les déshumidificateurs
Ta slovenski standard je istoveten z: EN 60335-2-40:2003
ICS:
23.120 =UDþQLNL9HWUQLNL.OLPDWVNH Ventilators. Fans. Air-
QDSUDYH conditioners
27.080 7RSORWQHþUSDONH Heat pumps
2003-01.Slovenski inštitut za standardizacijo. Razmnoževanje celote ali delov tega standarda ni dovoljeno.
EUROPEAN STANDARD EN 60335-2-40
NORME EUROPÉENNE
EUROPÄISCHE NORM March 2003
ICS 23.120 Supersedes EN 60335-2-40:1997 + A1:2000
Incorporates Corrigendum April 2006
English version
Household and similar electrical appliances -
Safety
Part 2-40: Particular requirements for electrical heat pumps,
air-conditioners and dehumidifiers
(IEC 60335-2-40:2002, modified)
Appareils électrodomestiques Sicherheit elektrischer Geräte für den
et analogues - Hausgebrauch und ähnliche Zwecke
Sécurité Teil 2-40: Besondere Anforderungen
Partie 2-40: Règles particulières für elektrisch betriebene Wärmepumpen,
pour les pompes à chaleur électriques, Klimageräte und Raumluft-Entfeuchter
les climatiseurs et les déshumidificateurs (IEC 60335-2-40:2002, modifiziert)
(CEI 60335-2-40:2002, modifiée)
This European Standard was approved by CENELEC on 2003-03-01. CENELEC members are bound to
comply with the CEN/CENELEC Internal Regulations which stipulate the conditions for giving this European
Standard the status of a national standard without any alteration.
Up-to-date lists and bibliographical references concerning such national standards may be obtained on
application to the Central Secretariat or to any CENELEC member.
This European Standard exists in three official versions (English, French, German). A version in any other
language made by translation under the responsibility of a CENELEC member into its own language and notified
to the Central Secretariat has the same status as the official versions.
CENELEC members are the national electrotechnical committees of Austria, Belgium, Czech Republic,
Denmark, Finland, France, Germany, Greece, Hungary, Iceland, Ireland, Italy, Luxembourg, Malta, Netherlands,
Norway, Portugal, Slovakia, Spain, Sweden, Switzerland and United Kingdom.
CENELEC
European Committee for Electrotechnical Standardization
Comité Européen de Normalisation Electrotechnique
Europäisches Komitee für Elektrotechnische Normung
Central Secretariat: rue de Stassart 35, B - 1050 Brussels
© 2003 CENELEC - All rights of exploitation in any form and by any means reserved worldwide for CENELEC members.
Ref. No. EN 60335-2-40:2003 E
Foreword
The text of document 61D/116/FDIS, future fourth edition of IEC 60335-2-40, prepared by SC 61D of the
IEC Technical Committee 61, was submitted to the IEC-CENELEC parallel vote.
As a result of the Kista meeting of CENELEC TC 61 in May 2002, a draft amendment prAA containing the
relevant existing common modifications was submitted to the formal vote.
The texts of the FDIS and the prAA were approved by CENELEC as a new edition of EN 60335-2-40 on
2003-03-01.
This European Standard replaces EN 60335-2-40:1997 + A1:2000.
The following dates are applicable:
- latest date by which the EN has to be implemented
at national level by publication of an identical
national standard or by endorsement (dop) 2004-03-01
- date on which national standards
conflicting with the EN have to be withdrawn (dow) 2007-03-01
This part 2 has to be used in conjunction with EN 60335-1, Household and similar electrical appliances –
Safety – Part 1: General requirements. It was established on the basis of the 2002 edition of that standard.
Amendments and revisions of Part 1 have also to be taken into account and the dates when such
changes become applicable will be stated in the relevant amendment or revision of Part 1.
This part 2 supplements or modifies the corresponding clauses of EN 60335-1, so as to convert it into the
European Standard: Safety requirements for electrical heat pumps, air-conditioners and dehumidifiers.
When a particular subclause of Part 1 is not mentioned in this part 2, that subclause applies as far as is
reasonable. When this standard states "addition", "modification" or "replacement", the relevant text of
Part 1 is to be adapted accordingly.
NOTE 1 The following numbering system is used:
- subclauses, tables and figures that are numbered starting from 101 are additional to those in Part 1;
- unless notes are in a new subclause or involve notes in Part 1, they are numbered starting from 101, including those in a
replaced clause or subclause;
- additional annexes are lettered AA, BB, etc.;
- subclauses, notes and annexes that are additional to those in the IEC standard are prefixed with the letter Z.
NOTE 2 The following print types are used:
- requirements: in roman type;
- test specifications: in italic type;
- notes: in small roman type.
Words in bold in the text are defined in Clause 3. When a definition concerns an adjective, the adjective and the associated noun
are also in bold.
There are no special national conditions causing a deviation from this European Standard, other than
those listed in Annex ZA to EN 60335-1.
There are no national deviations from this European Standard, other than those listed in Annex ZB to
EN 60335-1.
Annex AA is for information only.
p NOTE In this document, p is used in the margin to indicate instructions for preparing the printed version.
The contents of the corrigendum of April 2006 have been included in this copy.
_____________
- 3 - EN 60335-2-40:2003
Introduction
p Add:
An investigation by CENELEC TC 61 has shown that all risks from products within the scope of this
standard are fully covered by the Low Voltage Directive, 73/23/EEC. For products having mechanical
moving parts, a risk assessment in accordance with the Machinery Directive, 98/37/EC, has shown that
the risks are mainly of electrical origin and consequently this directive is not applicable. However, the
relevant essential safety requirements of the Machinery Directive are covered by this standard together
with the principal objectives of the Low Voltage Directive.
____________
Endorsement notice
The text of the International Standard IEC 60335-2-40:2002 was approved by CENELEC as a European
Standard with agreed common modifications as given below.
COMMON MODIFICATIONS
7 Marking and instructions
p 7.12.1 Add:
The installation instructions for appliances that are intended to be permanently connected to fixed wiring,
and have a leakage current that may exceed 10 mA, shall state that the installation of a residual current
device (RCD) having a rated residual operating current not exceeding 30 mA is advisable.
13 Leakage current and electric strength at operating temperature
p 13.2 Replace "the leakage current shall not exceed" by "the leakage current may exceed 3,5 mA but
shall not exceed”.
15 Moisture resistance
p Replace the first line by:
This clause of Part 1 is applicable except as follows.
p 15.1 Delete this subclause.
p 15.2 Delete this subclause.
p 15.3 Replace the subclause number by:
15.2 Addition:
16 Leakage current and electric strength
p 16.2 Replace "the leakage current shall not exceed" by "the leakage current may exceed 3,5 mA but
shall not exceed”.
__________
p Add:
Annex ZC
(normative)
Normative references to international publications
with their corresponding European publications
Publication Year Title EN/HD Year
IEC 60068-2-52 1996 Environmental testing – Part 2: Tests – EN 60068-2-52 1996
Test Kb: Salt mist, cyclic (sodium chloride
solution)
1) 2)
IEC 60335-2-34 – Household and similar electrical appliances – EN 60335-2-34 2002
Safety – Part 2-34: Particular requirements
for motor-compressors
1)
ISO 5149 – Mechanical refrigerating systems used for – –
cooling and heating – Safety requirements
____________
1)
undated reference
2)
valid edition at date of issue
INTERNATIONAL IEC
STANDARD
60335-2-40
Fourth edition
2002-12
Household and similar electrical appliances –
Safety –
Part 2-40:
Particular requirements for electrical heat pumps,
air conditioners and dehumidifiers
Appareils électrodomestiques et analogues –
Sécurité –
Partie 2-40:
Règles particulières pour les pompes à chaleur électriques,
les climatiseurs et les déshumidificateurs
IEC 2002 Copyright - all rights reserved
No part of this publication may be reproduced or utilized in any form or by any means, electronic or
mechanical, including photocopying and microfilm, without permission in writing from the publisher.
International Electrotechnical Commission, 3, rue de Varembé, PO Box 131, CH-1211 Geneva 20, Switzerland
Telephone: +41 22 919 02 11 Telefax: +41 22 919 03 00 E-mail: inmail@iec.ch Web: www.iec.ch
PRICE CODE
Commission Electrotechnique Internationale
W
International Electrotechnical Commission
Международная Электротехническая Комиссия
For price, see current catalogue
– 2 – 60335-2-40 IEC:2002(E)
CONTENTS
FOREWORD . 4
INTRODUCTION .6
1 Scope . 7
2 Normative references. 8
3 Definitions . 8
4 General requirement .10
5 General conditions for the tests .10
6 Classification .10
7 Marking and instructions .11
8 Protection against access to live parts .12
9 Starting of motor-operated appliances .13
10 Power input and current.13
11 Heating.13
12 Void .18
13 Leakage current and electric strength at operating temperature .18
14 Transient overvoltages.18
15 Moisture resistance.19
16 Leakage current and electric strength .19
17 Overload protection of transformers and associated circuits.20
18 Endurance .20
19 Abnormal operation.20
20 Stability and mechanical hazards.26
21 Mechanical strength.26
22 Construction .26
23 Internal wiring.28
24 Components .28
25 Supply connection and external flexible cords.29
26 Terminals for external conductors .29
27 Provision for earthing.29
28 Screws and connections .30
29 Clearances, creepage distances and solid insulation .30
30 Resistance to heat and fire .30
31 Resistance to rusting .30
32 Radiation, toxicity and similar hazards .30
Annexes.
...
Questions, Comments and Discussion
Ask us and Technical Secretary will try to provide an answer. You can facilitate discussion about the standard in here.