EN ISO 5983-2:2005

Animal feeding stuffs - Determination of nitrogen content and calculation of crude protein content - Part 2: Block digestion/steam distillation method (ISO 5983-2:2005)

Futtermittel - Bestimmung des Stickstoffgehaltes und Berechnung des Rohproteingehaltes - Teil 2: Blockaufschluss/Dampfdestillationsverfahren (ISO 5983-2:2005)

Dieser Teil von ISO 5983 legt ein Verfahren zur Bestimmung des Stickstoffgehaltes in Futtermitteln, Grünfutter und Futtermittelrohstoffen nach der Kjeldahl-Methode und ein Verfahren zur Berechnung des Rohproteingehaltes fest.
Es umfasst ein Halbmikro-Schnellverfahren unter Verwendung eines Blockaufschlusses mit Kupferkatalysator und Dampfdestillation in Borsäure.
Das Verfahren ist anwendbar zur Bestimmung von mehr als 0,5 % Kjeldahl-Stickstoff in Tierfuttermitteln, Haustierfutter und deren Rohmaterialien.
Mit diesem Verfahren können oxydierte Formen des Stickstoffs oder heterozyklische Stickstoffverbindungen nicht bestimmt werden.
Dieses Verfahren unterscheidet nicht zwischen Proteinstickstoff und Nichtproteinstickstoff.
ANMERKUNG   Ist es von Bedeutung, den Gehalt des Nichtproteinstickstoffs zu bestimmen, kann ein geeignetes Verfahren angewendet werden.

Aliments des animaux - Détermination de la teneur en azote et calcul de la teneur en protéines brutes - Partie 2: Méthode de digestion en bloc et distillation à la vapeur (ISO 5983-2:2005)

Krma - Določevanje dušika in izračun vsebnosti surovih beljakovin - 2. del: Metoda razklopa v bloku in destilacije z vodno paro (ISO 5983-2:2005)

General Information

• Status: Withdrawn
• Publication Date: 30-Jun-2005
• Withdrawal Date: 02-Jun-2009
• ICS: 65.120 - Animal feeding stuffs
• Technical Committee: CEN/TC 327 - Animal feeding stuffs - Methods of sampling and analysis
• Drafting Committee: CEN/TC 327 - Animal feeding stuffs - Methods of sampling and analysis
• Current Stage: 9960 - Withdrawal effective - Withdrawal
• Start Date: 03-Jun-2009
• Completion Date: 03-Jun-2009
• Ref Project: SIST EN ISO 5983-2:2005 - Animal feeding stuffs - Determination of nitrogen content and calculation of crude protein content - Part 2: Block digestion/steam distillation method (ISO 5983-2:2005)

Relations

• Replaced By: EN ISO 5983-2:2009 - Animal feeding stuffs - Determination of nitrogen content and calculation of crude protein content - Part 2: Block digestion and steam distillation method (ISO 5983-2:2009)
• Effective Date: 06-Jun-2009

Standards Content (Sample)

SLOVENSKI STANDARD
01-oktober-2005
.UPD'RORþHYDQMHGXãLNDLQL]UDþXQYVHEQRVWLVXURYLKEHOMDNRYLQGHO0HWRGD
UD]NORSDYEORNXLQGHVWLODFLMH]YRGQRSDUR,62
Animal feeding stuffs - Determination of nitrogen content and calculation of crude protein
content - Part 2: Block digestion/steam distillation method (ISO 5983-2:2005)
Futtermittel - Bestimmung des Stickstoffgehaltes und Berechnung des
Rohproteingehaltes - Teil 2: Blockaufschluss/Dampfdestillationsverfahren (ISO 5983-
2:2005)
Aliments des animaux - Détermination de la teneur en azote et calcul de la teneur en
protéines brutes - Partie 2: Méthode de digestion en bloc et distillation a la vapeur (ISO
5983-2:2005)
Ta slovenski standard je istoveten z: EN ISO 5983-2:2005
ICS:
65.120 Krmila Animal feeding stuffs
2003-01.Slovenski inštitut za standardizacijo. Razmnoževanje celote ali delov tega standarda ni dovoljeno.

EUROPEAN STANDARD
EN ISO 5983-2
NORME EUROPÉENNE
EUROPÄISCHE NORM
July 2005
ICS 65.120
English Version
Animal feeding stuffs - Determination of nitrogen content and
calculation of crude protein content - Part 2: Block
digestion/steam distillation method (ISO 5983-2:2005)
Aliments des animaux - Détermination de la teneur en Futtermittel - Bestimmung des Stickstoffgehaltes und
azote et calcul de la teneur en protéines brutes - Partie 2: Berechnung des Rohproteingehaltes - Teil 2:
Méthode de digestion en bloc et distillation à la vapeur (ISO Blockaufschluss/Dampfdestillationsverfahren (ISO 5983-
5983-2:2005) 2:2005)
This European Standard was approved by CEN on 1 June 2005.
CEN members are bound to comply with the CEN/CENELEC Internal Regulations which stipulate the conditions for giving this European
Standard the status of a national standard without any alteration. Up-to-date lists and bibliographical references concerning such national
standards may be obtained on application to the Central Secretariat or to any CEN member.
This European Standard exists in three official versions (English, French, German). A version in any other language made by translation
under the responsibility of a CEN member into its own language and notified to the Central Secretariat has the same status as the official
versions.
CEN members are the national standards bodies of Austria, Belgium, Cyprus, Czech Republic, Denmark, Estonia, Finland, France,
Germany, Greece, Hungary, Iceland, Ireland, Italy, Latvia, Lithuania, Luxembourg, Malta, Netherlands, Norway, Poland, Portugal, Slovakia,
Slovenia, Spain, Sweden, Switzerland and United Kingdom.
EUROPEAN COMMITTEE FOR STANDARDIZATION
COMITÉ EUROPÉEN DE NORMALISATION
EUROPÄISCHES KOMITEE FÜR NORMUNG
Management Centre: rue de Stassart, 36  B-1050 Brussels
© 2005 CEN All rights of exploitation in any form and by any means reserved Ref. No. EN ISO 5983-2:2005: E
worldwide for CEN national Members.

Foreword
This document (EN ISO 5983-2:2005) has been prepared by Technical Committee ISO/TC 34
"Agricultural food products" in collaboration with Technical Committee CEN/TC 327 "Animal
feeding stuffs - Methods of sampling and analysis", the secretariat of which is held by NEN.

This European Standard shall be given the status of a national standard, either by publication of
an identical text or by endorsement, at the latest by January 2006, and conflicting national
standards shall be withdrawn at the latest by January 2006.

According to the CEN/CENELEC Internal Regulations, the national standards organizations of
the following countries are bound to implement this European Standard: Austria, Belgium,
Cyprus, Czech Republic, Denmark, Estonia, Finland, France, Germany, Greece, Hungary,
Iceland, Ireland, Italy, Latvia, Lithuania, Luxembourg, Malta, Netherlands, Norway, Poland,
Portugal, Slovakia, Slovenia, Spain, Sweden, Switzerland and United Kingdom.

Endorsement notice
The text of ISO 5983-2:2005 has been approved by CEN as EN ISO 5983-2:2005 without any
modifications.
INTERNATIONAL ISO
STANDARD 5983-2
First edition
2005-07-01
Animal feeding stuffs — Determination of
nitrogen content and calculation of crude
protein content —
Part 2:
Block digestion/steam distillation method
Aliments des animaux — Détermination de la teneur en azote et calcul
de la teneur en protéines brutes —
Partie 1: Méthode de digestion en bloc et distillation à la vapeur

Reference number
ISO 5983-2:2005(E)
©
ISO 2005
ISO 5983-2:2005(E)
PDF disclaimer
This PDF file may contain embedded typefaces. In accordance with Adobe's licensing policy, this file may be printed or viewed but
shall not be edited unless the typefaces which are embedded are licensed to and installed on the computer performing the editing. In
downloading this file, parties accept therein the responsibility of not infringing Adobe's licensing policy. The ISO Central Secretariat
accepts no liability in this area.
Adobe is a trademark of Adobe Systems Incorporated.
Details of the software products used to create this PDF file can be found in the General Info relative to the file; the PDF-creation
parameters were optimized for printing. Every care has been taken to ensure that the file is suitable for use by ISO member bodies. In
the unlikely event that a problem relating to it is found, please inform the Central Secretariat at the address given below.

©  ISO 2005
All rights reserved. Unless otherwise specified, no part of this publication may be reproduced or utilized in any form or by any means,
electronic or mechanical, including photocopying and microfilm, without permission in writing from either ISO at the address below or
ISO's member body in the country of the requester.
ISO copyright office
Case postale 56 • CH-1211 Geneva 20
Tel. + 41 22 749 01 11
Fax + 41 22 749 09 47
E-mail [e-mail]
Web www.iso.org
Published in Switzerland
ii © ISO 2005 – All rights reserved

ISO 5983-2:2005(E)
Contents Page
Foreword. iv
1 Scope . 1
2 Normative references . 1
3 Terms and definitions. 2
4 Principle. 2
5 Reagents. 2
6 Apparatus . 4
7 Sampling. 4
8 Preparation of test sample. 5
9 Procedure . 5
10 Calculation and expression of results. 7
11 Precision. 8
12 Test report . 9
Annex A (informative) Results of interlaboratory test. 10
Annex B (informative) Automatic distillation with potentiometric endpoint detection. 13
Bibliography . 14

ISO 5983-2:2005(E)
Foreword
ISO (the International Organization for Standardization) is a worldwide federation of national standards bodies
(ISO member bodies). The work of preparing International Standards is normally carried out through ISO
technical committees. Each member body interested in a subject for which a technical committee has been
established has the right to be represented on that committee. International organizations, governmental and
non-governmental, in liaison with ISO, also take part in the work. ISO collaborates closely with the
International Electrotechnical Commission (IEC) on all matters of electrotechnical standardization.
International Standards are drafted in accordance with the rules given in the ISO/IEC Directives, Part 2.
The main task of technical committees is to prepare International Standards. Draft International Standards
adopted by the technical committees are circulated to the member bodies for voting. Publication as an
International Standard requires approval by at least 75 % of the member bodies casting a vote.
Attention is drawn to the possibility that some of the elements of this document may be the subject of patent
rights. ISO shall not be held responsible for identifying any or all such patent rights.
ISO 5983-2 was prepared by Technical Committee ISO/TC 34, Food products, Subcommittee SC 10, Animal
feeding stuffs.
This first edition of ISO 5983-2, together with ISO 5983-1:2005, cancels and replaces ISO 5983:1997, which
has been technically revised.
ISO 5983 consists of the following parts, under the general title Animal feeding stuffs — Determination of
nitrogen content and calculation of crude protein content:
 Part 1: Kjeldahl method
 Part 2: Block digestion/steam distillation

iv © ISO 2005 – All rights reserved

INTERNATIONAL STANDARD ISO 5983-2:2005(E)

Animal feeding stuffs — Determination of nitrogen content
and calculation of crude protein content —
Part 2:
Block digestion/steam distillation method
WARNING  The use of this method may involve the use of hazardous materials, operations and
equipment. This standard does not purport to address all the safety risks associated with its use. It is
the responsibility of the user of this method to establish appropriate health and safety practices and
determine the applicability of local regulatory limitations prior to use.
1 Scope
This part of ISO 5983 specifies a method for the determination of nitrogen content of animal feeding stuffs
according to the Kjeldahl method, and a method for the calculation of the crude protein content.
It concerns a semi-micro rapid routine method using block-digestion, copper catalyst and steam distillation into
boric acid.
The method is applicable to the determination of greater than 0,5 % Kjeldahl nitrogen in animal feeding stuffs,
pet foods and their raw materials.
The method does not measure oxidized forms of nitrogen nor heterocyclic nitrogen compounds.
The method does not distinguish between protein nitrogen and non-protein nitrogen.
NOTE If it is of importance to determine the content of non-protein-nitrogen, an appropriate method can be used.
2 Normative references
The following referenced documents are indispensable for the application of this document. For dated
references, only the edition cited applies. For undated references, the latest edition of the referred document
(including any amendments) applies.
ISO 385:2005, Laboratory glassware — Burettes
ISO 1871, Agricultural food products — General directions for the determination of nitrogen by the Kjeldahl
method
ISO 6498:1998, Animal feeding stuffs — Preparation of test samples
ISO 5983-2:2005(E)
3 Terms and definitions
For the purposes of this document, the following terms and definitions apply.
3.1
nitrogen content
mass fraction of nitrogen determined by the procedure specified in this document
NOTE The nitrogen content is expressed as a percentage by mass or in grams per kilogram.
3.2
crude protein content
amount of nitrogen content (3.1) multiplied by the factor 6,25
NOTE The crude protein content is expressed as a percentage by mass or in grams per kilogram.
4 Principle
The test portion is digested using a block-digestion or equivalent apparatus. Concentrated sulfuric acid is used
to convert protein nitrogen to ammonium sulfate at a boiling point elevated by the addition of potassium sulfate.
A copper catalyst is used to enhance the reaction rate. An excess of sodium hydroxide is added to the cooled
digest to liberate ammonia.
The liberated ammonia is distilled, using a manual, semi-automatic or fully automatic steam distillation unit. In
the case of manual or semi-automatic steam distillation, distillation of the ammonia into an excess of boric
acid solution is followed by titration with hydrochloric acid solution to a colorimetric endpoint. Where a fully
automatic system is employed, automatic titration of the ammonia is carried out simultaneously with the
distillation.
The nitrogen content is calculated from the amount of ammonia produced. The crude protein content is
obtained by multiplying the result by the conventional conversion factor of 6,25.
NOTE 1 As in ISO 5983-1, the automatic titration of the ammonia can also be carried out with endpoint detection using
a potentiometric pH system (see Annex B).
NOTE 2 In principle, sulfuric acid could also be used for the titration.
5 Reagents
Use only reagents of recognized analytical grade, unless otherwise specified, and distilled or demineralized
water or water of equivalent purity.
5.1 Kjeldahl catalyst tablets, comprising of 3,5 g of potassiu
...