SIST ISO 6588-1:2011
Paper, board and pulps -- Determination of pH of aqueous extracts -- Part 1: Cold extraction
Paper, board and pulps -- Determination of pH of aqueous extracts -- Part 1: Cold extraction
This part of ISO 6588 specifies a method for the determination of the pH-value defined by the electrolytes extractable by cold water from a sample of paper, board or pulp.
This part of ISO 6588 is applicable to all types of paper, board and pulp.
As the quantity of extractable ionic material approaches zero, as in the case of highly purified pulps, the precision of the method becomes poor because of the difficulties encountered in making pH measurements on water containing little electrolytic material.
Since the extraction in this part of ISO 6588 is performed with distilled or deionised water, the pH-value measured will sometimes be different (e.g. for fully bleached pulp) from the pH-value measured under mill process conditions in which various types of process waters, e.g. chemically treated river water containing electrolytes, are used.
ISO 6588-2 differs from this this part of ISO 6588 only as regards the extraction conditions. No general guidance can be given as to which of the two procedures (hot or cold) is best suited in a particular situation. For cellulosic papers used for electrical purposes, the method used should be that given in IEC 60554-2 (see [4] in the Bibliography).
Papier, carton et pâtes -- Détermination du pH des extraits aqueux -- Partie 1: Extraction à froid
L'ISO 6588-1:2005 spécifie une méthode pour la détermination de la valeur de pH définie par les électrolytes extractibles d'un échantillon de papier, de carton ou de pâte par de l'eau froide.
L'ISO 6588-1:2005 est applicable à tous les types de papiers, de cartons ou de pâtes.
Papir, karton, lepenka in vlaknine - Določanje pH vrednosti vodnih ekstraktov - 1. del: Ekstrakcija v hladnem
Ta del ISO 6588 opredeljuje metodo za določanje vrednosti pH, določene z elektroliti, ki se estrahirajo z mrzlo vodo iz vzorca papirja, kartona, lepenke ali vlaknin.
Ta del ISO 6588 velja za vse vrste papirja, kartona, lepenke in vlaknin.
Ko se količina ekstrahiranih ionskih materialov približuje nič kot pri visoko prečiščenih vlakninah, postane natančnost metode slaba zaradi težav, do katerih pride pri meritvah pH na vodi, ki vsebuje malo elektrolitskega materiala.
Ker ekstrakcija v tem delu ISO 6588 poteka z destilirano ali deionizirano vodo, bodo izmerjene vrednosti pH včasih različne (npr. za popolnoma beljene vlaknine) od vrednosti pH, merjenih v pogojih postopek mletja, pri katerem se uporabljajo različne vrste tehnološke vode, npr. kemično obdelane rečne vode, ki vsebujejo elektrolite.
ISO 6588-2 se razlikuje od tega dela ISO 6588 le glede pogojev ekstrakcije. Ni mogoče podati splošnega navodila, kateri od postopkov (vroči ali hladni) je primernejši v določeni situaciji. Za celulozne papirje, ki se uporabljajo za električne namene, je treba uporabiti metodo, ki je podana v IEC 60554-2 (glej [4] v bibliografiji).
General Information
Relations
Buy Standard
Standards Content (Sample)
МЕЖДУНАРОДНЫЙ ISO
СТАНДАРТ 6588-1
Первое издание
2005-05-15
Бумага, картон и целлюлоза.
Определение рН водных экстрактов.
Часть 1.
Холодное экстрагирование
Paper, board and pulps – Determination of pH of aqueous extracts –
Part 1: Cold extraction
Ответственность за подготовку русской версии несёт GOST R
(Российская Федерация) в соответствии со статьёй 18.1 Устава ISO
Ссылочный номер
ISO 6588-1:2005(R)
©
ISO 2005
---------------------- Page: 1 ----------------------
ISO 6588-1:2005(R)
Отказ от ответственности при работе в PDF
Настоящий файл PDF может содержать интегрированные шрифты. В соответствии с условиями лицензирования, принятыми
фирмой Adobe, этот файл можно распечатать или смотреть на экране, но его нельзя изменить, пока не будет получена
лицензия на установку интегрированных шрифтов в компьютере, на котором ведется редактирование. В случае загрузки
настоящего файла заинтересованные стороны принимают на себя ответственность за соблюдение лицензионных условий
фирмы Adobe. Центральный секретариат ISO не несет никакой ответственности в этом отношении.
Adobe - торговый знак фирмы Adobe Systems Incorporated.
Подробности, относящиеся к программным продуктам, использованным для создания настоящего файла PDF, можно найти в
рубрике General Info файла; параметры создания PDF были оптимизированы для печати. Были приняты во внимание все
меры предосторожности с тем, чтобы обеспечить пригодность настоящего файла для использования комитетами-членами
ISO. В редких случаях возникновения проблемы, связанной со сказанным выше, просьба проинформировать Центральный
секретариат по адресу, приведенному ниже.
ДОКУМЕНТ ОХРАНЯЕТСЯ АВТОРСКИМ ПРАВОМ
© ISO 2005
Если не указано иное, никакую часть настоящей публикации нельзя копировать или использовать в какой-либо форме или
каким-либо электронным или механическим способом, включая фотокопии и микрофильмы, без предварительного письменного
согласия ISO, которое должно быть получено после запроса о разрешении, направленного по адресу, приведенному ниже, или в
комитет-член ISO в стране запрашивающей стороны.
ISO copyright office
Case postale 56 • CH-1211 Geneva 20
Tel. + 41 22 749 01 11
Fax + 41 22 734 09 47
E-mail copyright @ iso.org
Web www.iso.org
Опубликовано в Швейцарии
ii © ISO 2005 – Все права сохраняются
---------------------- Page: 2 ----------------------
ISO 6588-1:2005(R)
Содержание Страница
Предисловие .iv
Введение .v
1 Область применения .1
2 Нормативные ссылки .1
3 Принцип.2
4 Реактивы .2
5 Аппаратура и оборудование .2
6 Отбор и приготовление образцов.2
7 Методика .3
8 Расчет .3
9 Сходимость.4
10 Протокол испытаний .4
Приложение А (информативное) Приготовление стандартных буферных растворов.5
Библиография.6
© ISO 2005 – Все права сохраняются iii
---------------------- Page: 3 ----------------------
ISO 6588-1:2005(R)
Предисловие
Международная организация по стандартизации (ISO) является всемирной федерацией национальных
организаций по стандартизации (комитетов-членов ISO). Разработка международных стандартов
обычно осуществляется техническими комитетами ISO. Каждый комитет-член ISO, заинтересованный
в деятельности, для которой был создан технический комитет, имеет право быть представленным в
этом комитете. Международные организации, правительственные и неправительственные, имеющие
связи с ISO, также принимают участие в работах. ISO непосредственно сотрудничает с
Международной электротехнической комиссией (IEC) по всем вопросам электротехнической
стандартизации.
Международные стандарты разрабатываются в соответствии с правилами, приведенными в
Директивах ISO/IEC, Часть 2.
Основная задача технических комитетов состоит в подготовке международных стандартов. Проекты
международных стандартов, одобренные техническими комитетами, рассылаются комитетам-членам
на голосование. Их опубликование в качестве международных стандартов требует одобрения, по
меньшей мере, 75 % комитетов-членов, принимающих участие в голосовании.
Следует иметь в виду, что некоторые элементы настоящего международного стандарта могут быть
объектом патентных прав. ISO не может нести ответственность за идентификацию какого-либо одного
или всех патентных прав.
Международный стандарт ISO 6588-1 разработан Техническим комитетом ISO/ТC 6, Бумага, картон и
целлюлоза.
Настоящее первое издание ISO 6588-1 вместе с ISO 6588-2 отменяет и заменяет международный
стандарт ISO 6588:1981, который был подвергнут техническому пересмотру. Работа, проведенная в
рамках Технического комитета ISO/ТC 6, показала, что результаты, полученные при использовании
методов, приведенных в двух частях ISO 6588, эквивалентны результатам, полученным при
использовании методов ISO 6588:1981. По сравнению с предыдущим изданием ISO 6588:1981
настоящее издание имеет четыре основных отличия:
a) ISO 6588 был разделен на две части: одна касается холодного экстрагирования, а другая –
горячего экстрагирования;
b) определение в настоящем издании выполняется на воздушно-сухом образце без определения
содержания сухого вещества, так как количество образца не является критическим;
c) экстракт фильтруется;
d) для ускорения измерения добавляется раствор соли.
ISO 6588 состоит из следующих частей под общим заголовком Бумага, картон и целлюлоза.
Определение рH водных экстрактов:
- Часть 1: Холодное экстрагирование
- Часть 2: Горячее экстрагирование
iv © ISO 2005 – Все права сохраняются
---------------------- Page: 4 ----------------------
ISO 6588-1:2005(R)
Введение
Хорошо известно, что крафт-фибра содержит способные к ионизации группы, которые закрепляются в
оболочке фибры или на ней. Для достижения электронейтральности эти группы уравновешиваются
эквивалентным количеством положительных зарядов, которыми могут быть либо протоны, либо ионы
различных металлов. Это явление может вызывать заметное несбалансированное распределение
подвижных ионов между объемом, удерживаемым оболочкой фибры, и объемом раствора суспензии,
особенно в случае суспензий целлюлозы с низкой ионной силой. Это означает, что фибра действует
как ионообменник. Эти явления ионного обмена очень хорошо моделируются с помощью теории
Donnan [2, 3].
При разбавлении относительно чистого образца целлюлозы, например, беленой сухой целлюлозы, в
деионизированной воде образуется суспензия целлюлозы, имеющая очень низкую ионную силу. В
такой системе большинство присутствующих катионов, включая протоны, будут концентрироваться в
объеме воды, удерживаемом оболочкой фибры. При измерении рН будет измеряться значение рН в
объеме раствора суспензии. При добавлении соли к системе такого типа явления ионного обмена
будут снижаться, и концентрация различных катионов будет одинаковой как в воде, удерживаемой
оболочкой фибры, так и в объеме раствора суспензии. Поскольку производственная вода всегда
содержит некоторое количество ионов, то такое добавление соли будет создавать окружающую среду
ближе к реальной при измерении рН относительно чистых образцов целлюлозы.
Необходимо знать об этих явлениях при интерпретации измеренных значений рН высоко
облагороженной целлюлозы.
© ISO 2005 – Все права сохраняются v
---------------------- Page: 5 ----------------------
МЕЖДУНАРОДНЫЙ СТАНДАРТ ISO 6588-1:2005(R)
Бумага, картон и целлюлоза. Определение рН водных
экстрактов.
Часть 1.
Холодное экстрагирование
1 Область применения
Настоящая часть ISO 6588 устанавливает метод определения значения рН в электролитах,
полученных при экстрагировании холодной водой образца бумаги, картона или целлюлозы.
Данная часть ISO 6588 применима ко всем типам бумаги, картона и целлюлозы.
Когда количество экстрагируемых ионных веществ приближается к нулю, как в случае высоко
облагороженной целлюлозы, сходимость метода становится низкой из-за трудностей, возникающих
при проведении измерений рН в воде, содержащей малое количество электролита.
Поскольку экстрагирование в этой части ISO 6588 проводится в дистиллированной или
деионизированной воде, значение рН иногда будет отличаться (например, для полностью отбеленной
целлюлозы) от значения рН, измеренного в условиях заводского процесса, в котором используются
различные типы производственной воды, например, химически обработанная речная вода,
содержащая электролиты.
Метод, установленный в ISO 6588-2, отличается от метода, описанного в данной части ISO 6588,
только условиями экстрагирования. Невоз
...
INTERNATIONAL ISO
STANDARD 6588-1
First edition
2005-05-15
Paper, board and pulps — Determination
of pH of aqueous extracts —
Part 1:
Cold extraction
Papier, carton et pâtes — Détermination du pH des extraits aqueux —
Partie 1: Extraction à froid
Reference number
ISO 6588-1:2005(E)
©
ISO 2005
---------------------- Page: 1 ----------------------
ISO 6588-1:2005(E)
PDF disclaimer
This PDF file may contain embedded typefaces. In accordance with Adobe's licensing policy, this file may be printed or viewed but
shall not be edited unless the typefaces which are embedded are licensed to and installed on the computer performing the editing. In
downloading this file, parties accept therein the responsibility of not infringing Adobe's licensing policy. The ISO Central Secretariat
accepts no liability in this area.
Adobe is a trademark of Adobe Systems Incorporated.
Details of the software products used to create this PDF file can be found in the General Info relative to the file; the PDF-creation
parameters were optimized for printing. Every care has been taken to ensure that the file is suitable for use by ISO member bodies. In
the unlikely event that a problem relating to it is found, please inform the Central Secretariat at the address given below.
© ISO 2005
All rights reserved. Unless otherwise specified, no part of this publication may be reproduced or utilized in any form or by any means,
electronic or mechanical, including photocopying and microfilm, without permission in writing from either ISO at the address below or
ISO's member body in the country of the requester.
ISO copyright office
Case postale 56 • CH-1211 Geneva 20
Tel. + 41 22 749 01 11
Fax + 41 22 749 09 47
E-mail copyright@iso.org
Web www.iso.org
Published in Switzerland
ii © ISO 2005 – All rights reserved
---------------------- Page: 2 ----------------------
ISO 6588-1:2005(E)
Contents Page
Foreword. iv
Introduction . v
1 Scope . 1
2 Normative references . 1
3 Principle. 1
4 Reagents. 2
5 Apparatus and equipment . 2
6 Sampling and preparation of sample. 2
7 Procedure . 2
8 Calculation. 3
9 Precision. 3
10 Test report . 4
Annex A (informative) Preparation of some standard buffer solutions. 5
Bibliography . 6
© ISO 2005 – All rights reserved iii
---------------------- Page: 3 ----------------------
ISO 6588-1:2005(E)
Foreword
ISO (the International Organization for Standardization) is a worldwide federation of national standards bodies
(ISO member bodies). The work of preparing International Standards is normally carried out through
ISO technical committees. Each member body interested in a subject for which a technical committee has
been established has the right to be represented on that committee. International organizations, governmental
and non-governmental, in liaison with ISO, also take part in the work. ISO collaborates closely with the
International Electrotechnical Commission (IEC) on all matters of electrotechnical standardization.
International Standards are drafted in accordance with the rules given in the ISO/IEC Directives, Part 2.
The main task of technical committees is to prepare International Standards. Draft International Standards
adopted by the technical committees are circulated to the member bodies for voting. Publication as an
International Standard requires approval by at least 75 % of the member bodies casting a vote.
Attention is drawn to the possibility that some of the elements of this document may be the subject of patent
rights. ISO shall not be held responsible for identifying any or all such patent rights.
ISO 6588-1 was prepared by Technical Committee ISO/TC 6, Paper, board and pulps.
This first edition of ISO 6588-1, together with ISO 6588-2, cancels and replaces ISO 6588:1981, which has
been technically revised. The work within ISO/TC 6 has shown that the results obtained with the two parts of
ISO 6588 are equivalent to those obtained in ISO 6588:1981. There are four major differences compared with
the previous edition of ISO 6588:1981:
a) ISO 6588 has been divided into two parts: one dealing with cold extraction and the other with hot
extraction;
b) the determination is now carried out on an air-dry sample without determination of dry matter content, as
the amount of sample is not critical;
c) the extract is filtered;
d) a salt solution is added to speed up the measurement.
ISO 6588 consists of the following parts, under the general title Paper, board and pulps — Determination of
pH of aqueous extracts:
Part 1: Cold extraction
Part 2: Hot extraction
iv © ISO 2005 – All rights reserved
---------------------- Page: 4 ----------------------
ISO 6588-1:2005(E)
Introduction
Kraft fibre is well known to contain ionisable groups that are fixed to or in the fibre wall. In order to fulfil the
electro-neutrality, these groups are balanced by an equivalent number of positive charges, which can be
either protons or various metal ions. Especially in pulp suspensions at low ionic strengths, this can give rise to
a marked uneven distribution of mobile ions between the volume held by the fibre wall and the bulk
suspension liquor. This means that the fibre acts as an ion exchanger. These ion-exchange phenomena can
be modelled very well with the Donnan theory [2, 3].
If a relatively clean pulp fibre sample, for example bleached dried pulp, is diluted in deionised water, the result
will be a pulp suspension with a very low ionic strength. In such a system, most of the cations present,
including protons, will be concentrated in the water volume held by the fibre wall. If the pH is measured, it will
be measured in the bulk suspension liquor. By adding salt to this kind of system, the ion exchange
phenomena will be decreased, and the concentration of different cations will be the same in the water held by
the fibre wall and in the bulk suspension liquor. Since the process waters always contain a certain amount of
ions, such a salt addition will give a more realistic environment when measuring the pH of relatively clean pulp
samples.
It is necessary to be aware of these effects when interpreting the measured pH-values of highly purified pulps.
© ISO 2005 – All rights reserved v
---------------------- Page: 5 ----------------------
INTERNATIONAL STANDARD ISO 6588-1:2005(E)
Paper, board and pulps — Determination of pH of aqueous
extracts —
Part 1:
Cold extraction
1 Scope
This part of ISO 6588 specifies a method for the determination of the pH-value defined by the electrolytes
extractable by cold water from a sample of paper, board or pulp.
This part of ISO 6588 is applicable to all types of paper, board and pulp.
As the quantity of extractable ionic material approaches zero, as in the case of highly purified pulps, the
precision of the method becomes poor because of the difficulties encountered in making pH measurements on
water containing little electrolytic material.
Since the extraction in this part of ISO 6588 is performed with distilled or deionised water, the pH-value
measured will sometimes be different (e.g. for fully bleached pulp) from the pH-value measured under mill
process conditions in which various types of process waters, e.g. chemically treated river water containing
electrolytes, are used.
ISO 6588-2 differs from this this part of ISO 6588 only as regards the extraction conditions. No general
guidance can be given as to which of the two procedures (hot or cold) is best suited in a particular situation.
For cellulosic papers used for electrical purposes, the method used should be that given in IEC 60554-2
...
SLOVENSKI STANDARD
SIST ISO 6588-1:2011
01-maj-2011
3DSLUNDUWRQOHSHQNDLQYODNQLQH'RORþDQMHS+YUHGQRVWLYRGQLKHNVWUDNWRY
GHO (NVWUDNFLMDYKODGQHP
Paper, board and pulps -- Determination of pH of aqueous extracts -- Part 1: Cold
extraction
Papier, carton et pâtes -- Détermination du pH des extraits aqueux -- Partie 1: Extraction
à froid
Ta slovenski standard je istoveten z: ISO 6588-1:2005
ICS:
85.040 Vlaknine Pulps
85.060 Papir, karton in lepenka Paper and board
SIST ISO 6588-1:2011 en
2003-01.Slovenski inštitut za standardizacijo. Razmnoževanje celote ali delov tega standarda ni dovoljeno.
---------------------- Page: 1 ----------------------
SIST ISO 6588-1:2011
---------------------- Page: 2 ----------------------
SIST ISO 6588-1:2011
INTERNATIONAL ISO
STANDARD 6588-1
First edition
2005-05-15
Paper, board and pulps — Determination
of pH of aqueous extracts —
Part 1:
Cold extraction
Papier, carton et pâtes — Détermination du pH des extraits aqueux —
Partie 1: Extraction à froid
Reference number
ISO 6588-1:2005(E)
©
ISO 2005
---------------------- Page: 3 ----------------------
SIST ISO 6588-1:2011
ISO 6588-1:2005(E)
PDF disclaimer
This PDF file may contain embedded typefaces. In accordance with Adobe's licensing policy, this file may be printed or viewed but
shall not be edited unless the typefaces which are embedded are licensed to and installed on the computer performing the editing. In
downloading this file, parties accept therein the responsibility of not infringing Adobe's licensing policy. The ISO Central Secretariat
accepts no liability in this area.
Adobe is a trademark of Adobe Systems Incorporated.
Details of the software products used to create this PDF file can be found in the General Info relative to the file; the PDF-creation
parameters were optimized for printing. Every care has been taken to ensure that the file is suitable for use by ISO member bodies. In
the unlikely event that a problem relating to it is found, please inform the Central Secretariat at the address given below.
© ISO 2005
All rights reserved. Unless otherwise specified, no part of this publication may be reproduced or utilized in any form or by any means,
electronic or mechanical, including photocopying and microfilm, without permission in writing from either ISO at the address below or
ISO's member body in the country of the requester.
ISO copyright office
Case postale 56 • CH-1211 Geneva 20
Tel. + 41 22 749 01 11
Fax + 41 22 749 09 47
E-mail copyright@iso.org
Web www.iso.org
Published in Switzerland
ii © ISO 2005 – All rights reserved
---------------------- Page: 4 ----------------------
SIST ISO 6588-1:2011
ISO 6588-1:2005(E)
Contents Page
Foreword. iv
Introduction . v
1 Scope . 1
2 Normative references . 1
3 Principle. 1
4 Reagents. 2
5 Apparatus and equipment . 2
6 Sampling and preparation of sample. 2
7 Procedure . 2
8 Calculation. 3
9 Precision. 3
10 Test report . 4
Annex A (informative) Preparation of some standard buffer solutions. 5
Bibliography . 6
© ISO 2005 – All rights reserved iii
---------------------- Page: 5 ----------------------
SIST ISO 6588-1:2011
ISO 6588-1:2005(E)
Foreword
ISO (the International Organization for Standardization) is a worldwide federation of national standards bodies
(ISO member bodies). The work of preparing International Standards is normally carried out through
ISO technical committees. Each member body interested in a subject for which a technical committee has
been established has the right to be represented on that committee. International organizations, governmental
and non-governmental, in liaison with ISO, also take part in the work. ISO collaborates closely with the
International Electrotechnical Commission (IEC) on all matters of electrotechnical standardization.
International Standards are drafted in accordance with the rules given in the ISO/IEC Directives, Part 2.
The main task of technical committees is to prepare International Standards. Draft International Standards
adopted by the technical committees are circulated to the member bodies for voting. Publication as an
International Standard requires approval by at least 75 % of the member bodies casting a vote.
Attention is drawn to the possibility that some of the elements of this document may be the subject of patent
rights. ISO shall not be held responsible for identifying any or all such patent rights.
ISO 6588-1 was prepared by Technical Committee ISO/TC 6, Paper, board and pulps.
This first edition of ISO 6588-1, together with ISO 6588-2, cancels and replaces ISO 6588:1981, which has
been technically revised. The work within ISO/TC 6 has shown that the results obtained with the two parts of
ISO 6588 are equivalent to those obtained in ISO 6588:1981. There are four major differences compared with
the previous edition of ISO 6588:1981:
a) ISO 6588 has been divided into two parts: one dealing with cold extraction and the other with hot
extraction;
b) the determination is now carried out on an air-dry sample without determination of dry matter content, as
the amount of sample is not critical;
c) the extract is filtered;
d) a salt solution is added to speed up the measurement.
ISO 6588 consists of the following parts, under the general title Paper, board and pulps — Determination of
pH of aqueous extracts:
Part 1: Cold extraction
Part 2: Hot extraction
iv © ISO 2005 – All rights reserved
---------------------- Page: 6 ----------------------
SIST ISO 6588-1:2011
ISO 6588-1:2005(E)
Introduction
Kraft fibre is well known to contain ionisable groups that are fixed to or in the fibre wall. In order to fulfil the
electro-neutrality, these groups are balanced by an equivalent number of positive charges, which can be
either protons or various metal ions. Especially in pulp suspensions at low ionic strengths, this can give rise to
a marked uneven distribution of mobile ions between the volume held by the fibre wall and the bulk
suspension liquor. This means that the fibre acts as an ion exchanger. These ion-exchange phenomena can
be modelled very well with the Donnan theory [2, 3].
If a relatively clean pulp fibre sample, for example bleached dried pulp, is diluted in deionised water, the result
will be a pulp suspension with a very low ionic strength. In such a system, most of the cations present,
including protons, will be concentrated in the water volume held by the fibre wall. If the pH is measured, it will
be measured in the bulk suspension liquor. By adding salt to this kind of system, the ion exchange
phenomena will be decreased, and the concentration of different cations will be the same in the water held by
the fibre wall and in the bulk suspension liquor. Since the process waters always contain a certain amount of
ions, such a salt addition will give a more realistic environment when measuring the pH of relatively clean pulp
samples.
It is necessary to be aware of these effects when interpreting the measured pH-values of highly purified pulps.
© ISO 2005 – All rights reserved v
---------------------- Page: 7 ----------------------
SIST ISO 6588-1:2011
---------------------- Page: 8 ----------------------
SIST ISO 6588-1:2011
INTERNATIONAL STANDARD ISO 6588-1:2005(E)
Paper, board and pulps — Determination of pH of aqueous
extracts —
Part 1:
Cold extraction
1 Scope
This part of ISO 6588 specifies a method for the determination of the pH-value defined by the electrolytes
extractable by cold water from a sample of paper, board or pulp.
This part of ISO 6588 is applicable to all types of paper, board and pulp.
As the quantity of extractable ionic material approaches zero, as in the case of highly purified pulps, the
precision of the method becomes poor because of the difficulties encountered in making pH measurements on
water containing little electrolytic material.
Since the extraction in this part of ISO 6588 is performed with distilled or deionised water, the pH-value
measured will sometimes be different (e.g. for fully bl
...
NORME ISO
INTERNATIONALE 6588-1
Première édition
2005-05-15
Papier, carton et pâtes — Détermination
du pH des extraits aqueux —
Partie 1:
Extraction à froid
Paper, board and pulps — Determination of pH of aqueous extracts —
Part 1: Cold extraction
Numéro de référence
ISO 6588-1:2005(F)
©
ISO 2005
---------------------- Page: 1 ----------------------
ISO 6588-1:2005(F)
PDF – Exonération de responsabilité
Le présent fichier PDF peut contenir des polices de caractères intégrées. Conformément aux conditions de licence d'Adobe, ce fichier
peut être imprimé ou visualisé, mais ne doit pas être modifié à moins que l'ordinateur employé à cet effet ne bénéficie d'une licence
autorisant l'utilisation de ces polices et que celles-ci y soient installées. Lors du téléchargement de ce fichier, les parties concernées
acceptent de fait la responsabilité de ne pas enfreindre les conditions de licence d'Adobe. Le Secrétariat central de l'ISO décline toute
responsabilité en la matière.
Adobe est une marque déposée d'Adobe Systems Incorporated.
Les détails relatifs aux produits logiciels utilisés pour la création du présent fichier PDF sont disponibles dans la rubrique General Info
du fichier; les paramètres de création PDF ont été optimisés pour l'impression. Toutes les mesures ont été prises pour garantir
l'exploitation de ce fichier par les comités membres de l'ISO. Dans le cas peu probable où surviendrait un problème d'utilisation,
veuillez en informer le Secrétariat central à l'adresse donnée ci-dessous.
© ISO 2005
Droits de reproduction réservés. Sauf prescription différente, aucune partie de cette publication ne peut être reproduite ni utilisée sous
quelque forme que ce soit et par aucun procédé, électronique ou mécanique, y compris la photocopie et les microfilms, sans l'accord écrit
de l'ISO à l'adresse ci-après ou du comité membre de l'ISO dans le pays du demandeur.
ISO copyright office
Case postale 56 • CH-1211 Geneva 20
Tel. + 41 22 749 01 11
Fax. + 41 22 749 09 47
E-mail copyright@iso.org
Web www.iso.org
Publié en Suisse
ii © ISO 2005 – Tous droits réservés
---------------------- Page: 2 ----------------------
ISO 6588-1:2005(F)
Sommaire Page
Avant-propos. iv
Introduction . v
1 Domaine d'application. 1
2 Références normatives . 1
3 Principe. 1
4 Réactifs . 2
5 Appareillage et équipement. 2
6 Échantillonnage et préparation de l'échantillon. 2
7 Mode opératoire . 2
8 Calculs . 3
9 Fidélité . 3
10 Rapport d'essai . 4
Annexe A (informative) Préparation des solutions tampons étalons . 5
Bibliographie . 6
© ISO 2005 – Tous droits réservés iii
---------------------- Page: 3 ----------------------
ISO 6588-1:2005(F)
Avant-propos
L'ISO (Organisation internationale de normalisation) est une fédération mondiale d'organismes nationaux de
normalisation (comités membres de l'ISO). L'élaboration des Normes internationales est en général confiée
aux comités techniques de l'ISO. Chaque comité membre intéressé par une étude a le droit de faire partie du
comité technique créé à cet effet. Les organisations internationales, gouvernementales et non
gouvernementales, en liaison avec l'ISO participent également aux travaux. L'ISO collabore étroitement avec
la Commission électrotechnique internationale (CEI) en ce qui concerne la normalisation électrotechnique.
Les Normes internationales sont rédigées conformément aux règles données dans les Directives ISO/CEI,
Partie 2.
La tâche principale des comités techniques est d'élaborer les Normes internationales. Les projets de Normes
internationales adoptés par les comités techniques sont soumis aux comités membres pour vote. Leur
publication comme Normes internationales requiert l'approbation de 75 % au moins des comités membres
votants.
L'attention est appelée sur le fait que certains des éléments du présent document peuvent faire l'objet de
droits de propriété intellectuelle ou de droits analogues. L'ISO ne saurait être tenue pour responsable de ne
pas avoir identifié de tels droits de propriété et averti de leur existence.
L'ISO 6588-1 a été élaborée par le comité technique ISO/TC 6, Papiers, cartons et pâtes.
Cette première édition de l'ISO 6588-1, ainsi que l’ISO 6588-2, annule et remplace l'ISO 6588:1981, qui a fait
l'objet d'une révision technique. Des travaux dans le cadre de l'ISO/TC 6 ont démontré que les résultats
obtenus avec les deux parties de l’ISO 6588 sont égaux à ceux obtenus avec l’ISO 6588:1981. Il y a quatre
différences majeures par rapport à l'édition précédente, l’ISO 6588:1981:
a) l’ISO 6588 a été séparée en deux parties, l’une pour l'extraction à froid et l'autre pour l'extraction à chaud;
b) la détermination est maintenant effectuée sur un échantillon séché à l'air, sans détermination de la teneur
en matière sèche, puisque la quantité de l'échantillon n'est pas critique;
c) l'extrait est filtré;
d) une solution saline est ajoutée pour rendre la détermination plus rapide.
L'ISO 6588 comprend les parties suivantes, présentées sous le titre général Papier, carton et pâtes —
Détermination du pH des extraits aqueux:
Partie 1: Extraction à froid
Partie 2: Extraction à chaud
iv © ISO 2005 – Tous droits réservés
---------------------- Page: 4 ----------------------
ISO 6588-1:2005(F)
Introduction
Il est bien connu que la fibre kraft contient des groupes ionisables qui sont fixés à ou se trouvent à l'intérieur
de la paroi de la fibre. Afin de satisfaire l'électroneutralité, ces groupes sont équilibrés par un nombre égal de
charges positives, qui peuvent être des protons ou des ions métalliques divers. En particulier dans les pâtes
de faible concentration ionique, cela peut mener à une distribution inégale des ions mobiles entre le volume
emprisonné dans la paroi de la fibre et le reste de la suspension. Cela signifie que la fibre agit en tant
qu'échangeur d'ions. Ce phénomène d'échange d'ions peut être modélisé très bien en utilisant la théorie de
Donnan [2,3].
Si un échantillon de pâte de fibres relativement propre, par exemple une pâte blanchie et séchée, est dilué
dans de l'eau déionisée, le résultat sera une pâte en suspension de très faible concentration ionique. Dans un
tel système, la plupart des cations présents, incluant les protons, seront concentrés dans un volume d'eau
retenu par la paroi de la fibre. Si le pH est mesuré, il sera mesuré dans la pâte environnante. En ajoutant un
sel à ce type de système, le phénomène d'échange d'ions sera diminué et la concentration des différents
cations sera identique dans l'eau emprisonnée par la paroi de la fibre et le reste de la pâte en suspension.
Puisque les eaux de procédés contiennent toujours une certaine quantité d'ions, un tel ajout d'un sel résultera
en un environnement plus réaliste lors de la mesure du pH d'échantillons de pâtes relativement propres.
Il est nécessaire d'être conscient de ces effets lors de l'interprétation des valeurs de pH telles que mesurées
pour des pâtes hautement purifiées.
© ISO 2005 – Tous droits réservés v
---------------------- Page: 5 ----------------------
NORME INTERNATIONALE ISO 6588-1:2005(F)
Papier, carton et pâtes — Détermination du pH des extraits
aqueux —
Partie 1:
Extraction à froid
1 Domaine d'application
La présente partie de l’ISO 6588 spécifie une méthode pour la détermination de la valeur de pH définie par les
électrolytes extractibles d'un échantillon de papier, de carton ou de pâte, par de l'eau froide.
La présente partie de l’ISO 6588 est applicable à tous les types de papiers, de cartons ou de pâtes.
Lorsque la quantité de substance ionique extractible est presque nulle, comme dans le cas des pâtes
hautement purifiées, la précision de cette méthode devient mauvaise à cause des difficultés engendrées par
la mesure du pH d'une eau contenant peu de substances électrolytiques.
Puisque l'extraction dans la présente partie de l’ISO 6588 est effectuée avec de l'eau distillée ou de l'eau
déionisée, la valeur de pH mesurée sera parfois différente (par exemple pour une pâte hautement blanchie)
de la valeur de pH mesurée sous les conditions d'opération à l'usine, alors que différents types d'eaux de
procédé, par exemple de l'eau de rivière traitée chimiquement contenant des électrolytes, sont utilisées.
L’ISO 6588-2 diffère de la présente partie de l’ISO 6588 seulement en ce qui à trait aux conditions d'extraction.
Aucun conseil général ne peut être fourni quant à laquelle des deux méthodes (à froid ou à chaud) est
indiquée dans une situation particulière.
Pour les papiers cellulosiques à usages électriques, il est recommandé que la méthode utilisée soit celle de la
CEI 60554-2 (voir [4] dans l
...
2003-01.Slovenski inštitut za standardizacijo. Razmnoževanje celote ali delov tega standarda ni dovoljeno.Papier, carton et pâtes -- Détermination du pH des extraits aqueux -- Partie 1: Extraction à froidPaper, board and pulps -- Determination of pH of aqueous extracts -- Part 1: Cold extraction85.060Papir, karton in lepenkaPaper and board85.040VlakninePulpsICS:Ta slovenski standard je istoveten z:ISO 6588-1:2005oSIST ISO 6588-1:2011en01-marec-2011oSIST ISO 6588-1:2011SLOVENSKI
STANDARD
oSIST ISO 6588-1:2011
Reference numberISO 6588-1:2005(E)© ISO 2005
INTERNATIONAL STANDARD ISO6588-1First edition2005-05-15Paper, board and pulps — Determination of pH of aqueous extracts — Part 1: Cold extraction Papier, carton et pâtes — Détermination du pH des extraits aqueux — Partie 1: Extraction à froid
oSIST ISO 6588-1:2011
ISO 6588-1:2005(E) PDF disclaimer This PDF file may contain embedded typefaces. In accordance with Adobe's licensing policy, this file may be printed or viewed but shall not be edited unless the typefaces which are embedded are licensed to and installed on the computer performing the editing. In downloading this file, parties accept therein the responsibility of not infringing Adobe's licensing policy. The ISO Central Secretariat accepts no liability in this area. Adobe is a trademark of Adobe Systems Incorporated. Details of the software products used to create this PDF file can be found in the General Info relative to the file; the PDF-creation parameters were optimized for printing. Every care has been taken to ensure that the file is suitable for use by ISO member bodies. In the unlikely event that a problem relating to it is found, please inform the Central Secretariat at the address given below.
©
ISO 2005 All rights reserved. Unless otherwise specified, no part of this publication may be reproduced or utilized in any form or by any means, electronic or mechanical, including photocopying and microfilm, without permission in writing from either ISO at the address below or ISO's member body in the country of the requester. ISO copyright office Case postale 56 • CH-1211 Geneva 20 Tel.
+ 41 22 749 01 11 Fax
+ 41 22 749 09 47 E-mail
copyright@iso.org Web
www.iso.org Published in Switzerland
ii © ISO 2005 – All rights reserved
oSIST ISO 6588-1:2011
ISO 6588-1:2005(E) © ISO 2005 – All rights reserved iiiContents Page Foreword.iv Introduction.v 1 Scope.1 2 Normative references.1 3 Principle.1 4 Reagents.2 5 Apparatus and equipment.2 6 Sampling and preparation of sample.2 7 Procedure.2 8 Calculation.3 9 Precision.3 10 Test report.4 Annex A (informative)
Preparation of some standard buffer solutions.5 Bibliography.6
oSIST ISO 6588-1:2011
ISO 6588-1:2005(E) iv © ISO 2005 – All rights reserved Foreword ISO (the International Organization for Standardization) is a worldwide federation of national standards bodies (ISO member bodies). The work of preparing International Standards is normally carried out through ISO technical committees. Each member body interested in a subject for which a technical committee has been established has the right to be represented on that committee. International organizations, governmental and non-governmental, in liaison with ISO, also take part in the work. ISO collaborates closely with the International Electrotechnical Commission (IEC) on all matters of electrotechnical standardization. International Standards are drafted in accordance with the rules given in the ISO/IEC Directives, Part 2. The main task of technical committees is to prepare International Standards. Draft International Standards adopted by the technical committees are circulated to the member bodies for voting. Publication as an International Standard requires approval by at least 75 % of the member bodies casting a vote. Attention is drawn to the possibility that some of the elements of this document may be the subject of patent rights. ISO shall not be held responsible for identifying any or all such patent rights. ISO 6588-1 was prepared by Technical Committee ISO/TC 6, Paper, board and pulps. This first edition of ISO 6588-1, together with ISO 6588-2, cancels and replaces ISO 6588:1981, which has been technically revised. The work within ISO/TC 6 has shown that the results obtained with the two parts of ISO 6588 are equivalent to those obtained in ISO 6588:1981. There are four major differences compared with the previous edition of ISO 6588:1981: a) ISO 6588 has been divided into two parts: one dealing with cold extraction and the other with hot extraction;
b) the determination is now carried out on an air-dry sample without determination of dry matter content, as the amount of sample is not critical; c)
the extract is filtered; d) a salt solution is added to speed up the measurement. ISO 6588 consists of the following parts, under the general title Paper, board and pulps — Determination of pH of aqueous extracts: Part 1: Cold extraction Part 2: Hot extraction
oSIST ISO 6588-1:2011
ISO 6588-1:2005(E) © ISO 2005 – All rights reserved vIntroduction Kraft fibre is well known to contain ionisable groups that are fixed to or in the fibre wall. In order to fulfil the electro-neutrality, these groups are balanced by an equivalent number of positive charges, which can be either protons or various metal ions. Especially in pulp suspensions at low ionic strengths, this can give rise to a marked uneven distribution of mobile ions between the volume held by the fibre wall and the bulk suspension liquor. This means that the fibre acts as an ion exchanger. These ion-exchange phenomena can be modelled very well with the Donnan theory [2, 3]. If a relatively clean pulp fibre sample, for example bleached dried pulp, is diluted in deionised water, the result will be a pulp suspension with a very low ionic strength. In such a system, most of the cations present, including protons, will be concentrated in the water volume held by the fibre wall. If the pH is measured, it will be measured in the bulk suspension liquor. By adding salt to this kind of system, the ion exchange phenomena will be decreased, and the concentration of different cations will be the same in the water held by the fibre wall and in the bulk suspension liquor. Since the process waters always contain a certain amount of ions, such a salt addition will give a more realistic environment when measuring the pH of relatively clean pulp samples. It is necessary to be aware of these effects when interpreting the measured pH-values of highly purified pulps.
oSIST ISO 6588-1:2011
oSIST ISO 6588-1:2011
INTERNATIONAL STANDARD ISO 6588-1:2005(E) © ISO 2005 – All rights reserved 1Paper, board and pulps — Determination of pH of aqueous extracts — Part 1: Cold extraction 1 Scope This part of ISO 6588 specifies a method for the determination of the pH-value defined by the electrolytes extractable by cold water from a sample of paper, board or pulp.
This part of ISO 6588 is applicable to all types of paper, board and pulp. As the quantity of extractable ionic material approaches zero, as in the case of highly purified pulps, the precision of the method becomes poor because of the difficulties encountered in making pH measurements on water containing little electrolytic material. Since the extraction in this part of ISO 6588 is performed with distilled or deionised water, the pH-value measured will sometimes be different (e.g. for fully bleached pulp) from the pH-value measured under mill process conditions in which various types
...
Questions, Comments and Discussion
Ask us and Technical Secretary will try to provide an answer. You can facilitate discussion about the standard in here.