SIST EN 60335-2-108:2008

Household and similar electrical appliances - Safety -- Part 2-108: Particular requirements for electrolysers

This clause of Part 1 is replaced by the following. This International Standard deals with the safety of electrolysers that produce low viscosity, ionized liquids intended for use as detergent free wash water in appliances for household and similar purposes and which conform with the standards applicable to such appliances. It applies to electrolysers tested separately, under the most severe conditions that may be expected to occur in normal use, their rated voltage being not more than 250 V.

Sicherheit elektrischer Geräte für den Hausgebrauch und ähnliche Zwecke - Teil 2-108: Besondere Anforderungen für Elektrolysatoren

Appareils électrodomestiques et analogues - Sécurité -- Partie 2-108: Règles particulières pour les électrolyseurs

Traite de la sécurité des électrolyseurs qui produisent des liquides ionisés à faible viscosité destinés à être utilisés comme eau de lavage sans détergent dans les appareils à usages domestiques et analogues et qui sont conformes aux normes applicables à de tels appareils. Elle s'applique aux électrolyseurs essayés séparément, dans les conditions les plus sévères qui peuvent se produire en usage normal, et dont la tension assignée n'est pas supérieure à 250 V. L'attention des Comités Nationaux est attirée sur le fait que les fabricants d'appareils et les organismes d'essai peuvent avoir besoin d'une période transitoire après la publication d'une nouvelle publication CEI, ou d'une publication amendée ou révisée, pour fabriquer des produits conformes aux nouvelles exigences et pour adapter leurs équipements aux nouveaux essais ou aux essais révisés. Le comité recommande que le contenu de la présente norme soit entériné au niveau national au plus tôt 12 mois après sa date de publication.

Gospodinjski in podobni električni aparati - Varnost - 2-108. del: Posebne zahteve za elektrolizatorje (IEC 60335-2-108:2008, spremenjen)

General Information

• Status: Published
• Publication Date: 25-Sep-2008
• ICS: 13.120 - Domestic safety
• ICS: 97.060 - Laundry appliances
• Technical Committee: VGA - Safety of household and similar electrical appliances
• Current Stage: 6060 - National Implementation/Publication (Adopted Project)
• Start Date: 15-Sep-2008
• Due Date: 20-Nov-2008
• Completion Date: 26-Sep-2008
• Directive: 2006/95/EC - Directive 2006/95/EC of the European Parliament and of the Council of 12 December 2006 on the harmonisation of the laws of Member States relating to electrical equipment designed for use within certain voltage limits (codified version)
• Directive: 2014/35/EU - Directive 2014/35/EU of the European Parliament and of the Council of 26 February 2014 on the harmonisation of the laws of the Member States relating to the making available on the market of electrical equipment designed for use within certain voltage limits
• Directive: 73/23/EEC - Electrical equipment designed for use within certain voltage limits
• Ref Project: EN 60335-2-108:2008 - Household and similar electrical appliances - Safety - Part 2-108: Particular requirements for electrolysers

Standards Content (Sample)

SLOVENSKI STANDARD
SIST EN 60335-2-108:2008
01-november-2008
*RVSRGLQMVNLLQSRGREQLHOHNWULþQLDSDUDWL9DUQRVWGHO3RVHEQH]DKWHYH
]DHOHNWUROL]DWRUMH,(&VSUHPHQMHQ
Household and similar electrical appliances - Safety - Part 2-108: Particular requirements
for electrolysers
Sicherheit elektrischer Geräte für den Hausgebrauch und ähnliche Zwecke - Teil 2-108:
Besondere Anforderungen für Elektrolysatoren
Appareils électrodomestiques et analogues - Sécurité - Partie 2-108: Règles particulières
pour les électrolyseurs
Ta slovenski standard je istoveten z: EN 60335-2-108:2008
ICS:
13.120 Varnost na domu Domestic safety
97.060 Aparati za nego perila Laundry appliances
SIST EN 60335-2-108:2008 en,fr,de
2003-01.Slovenski inštitut za standardizacijo. Razmnoževanje celote ali delov tega standarda ni dovoljeno.

---------------------- Page: 1 ----------------------

SIST EN 60335-2-108:2008

---------------------- Page: 2 ----------------------

SIST EN 60335-2-108:2008

EUROPEAN STANDARD
EN 60335-2-108

NORME EUROPÉENNE
July 2008
EUROPÄISCHE NORM

ICS 13.120; 97.060


English version


Household and similar electrical appliances -
Safety -
Part 2-108: Particular requirements for electrolysers
(IEC 60335-2-108:2008, modified)


Appareils électrodomestiques  Sicherheit elektrischer Geräte
et analogues - für den Hausgebrauch
Sécurité - und ähnliche Zwecke -
Partie 2-108: Règles particulières Teil 2-108: Besondere Anforderungen
pour les électrolyseurs für Elektrolysatoren
(CEI 60335-2-108:2008, modifiée) (IEC 60335-2-108:2008, modifiziert)




This European Standard was approved by CENELEC on 2008-05-01. CENELEC members are bound to comply
with the CEN/CENELEC Internal Regulations which stipulate the conditions for giving this European Standard
the status of a national standard without any alteration.

Up-to-date lists and bibliographical references concerning such national standards may be obtained on
application to the Central Secretariat or to any CENELEC member.

This European Standard exists in three official versions (English, French, German). A version in any other
language made by translation under the responsibility of a CENELEC member into its own language and notified
to the Central Secretariat has the same status as the official versions.

CENELEC members are the national electrotechnical committees of Austria, Belgium, Bulgaria, Cyprus, the
Czech Republic, Denmark, Estonia, Finland, France, Germany, Greece, Hungary, Iceland, Ireland, Italy, Latvia,
Lithuania, Luxembourg, Malta, the Netherlands, Norway, Poland, Portugal, Romania, Slovakia, Slovenia, Spain,
Sweden, Switzerland and the United Kingdom.

CENELEC
European Committee for Electrotechnical Standardization
Comité Européen de Normalisation Electrotechnique
Europäisches Komitee für Elektrotechnische Normung

Central Secretariat: rue de Stassart 35, B - 1050 Brussels


© 2008 CENELEC - All rights of exploitation in any form and by any means reserved worldwide for CENELEC members.
Ref. No. EN 60335-2-108:2008 E

---------------------- Page: 3 ----------------------

SIST EN 60335-2-108:2008
EN 60335-2-108:2008 - 2 -
Foreword
The text of document 61/3413/FDIS, future edition 1 of IEC 60335-2-108, prepared by IEC Technical
Committee 61, Safety of household and similar electrical appliances, was submitted to the IEC-CENELEC
parallel vote and was approved by CENELEC as EN 60335-2-108 on 2008-05-01 with a common
modification maintaining the coherence with Clause 6 of EN 60335-1:2002.
The following dates are applicable:
– latest date by which the EN has to be implemented
at national level by publication of an identical
(dop) 2009-02-01
national standard or by endorsement
– latest date by which the national standards conflicting
(dow) 2011-05-01
with the EN have to be withdrawn
This part 2 has to be used in conjunction with EN 60335-1, Household and similar electrical appliances –
Safety – Part 1: General requirements. It was established on the basis of the 2002 edition of that
standard. Amendments and revisions of Part 1 have also to be taken into account and the dates when
such changes become applicable will be stated in the relevant amendment of revision of Part 1.
This part 2 supplements or modifies the corresponding clauses in EN 60335-1, so as to convert it into the
European Standard: Safety requirements for electrical electrolysers.
When a particular subclause of Part 1 is not mentioned in this part 2, that subclause applies as far as is
reasonable. When this standard states "addition", "modification" or "replacement", the relevant text in
Part 1 is to be adapted accordingly.
NOTE 1 The following numbering system is used:
– subclauses, tables and figures that are numbered starting from 101 are additional to those in Part 1;
– unless notes are in a new subclause or involve notes in Part 1, they are numbered starting from 101, including those in a
replaced clause or subclause;
– additional annexes are lettered AA, BB, etc.
– subclauses, notes and annexes that are additional to those in the IEC standard are prefixed with the letter Z.
NOTE 2 The following print types are used:
– requirements: in roman type;
– test specifications: in italic type;
– notes: in small roman type.
Words in bold in the text are defined in Clause 3. When a definition concerns an adjective, the adjective and the associated noun
are also in bold.
There are no special national conditions causing a deviation from this European Standard, other than
those listed in Annex ZA to EN 60335-1.
There are no national deviations from this European Standard, other than those listed in Annex ZB to
EN 60335-1.
p NOTE  In this document, p is used in the margin to indicate instructions for preparing the printed version.
__________

---------------------- Page: 4 ----------------------

SIST EN 60335-2-108:2008
- 3 - EN 60335-2-108:2008
Introduction
p Add:

An investigation by CENELEC TC 61 has shown that all risks from products within the scope of this
standard are fully covered by the Low Voltage Directive, 2006/95/EC. For products having mechanical
moving parts, a risk assessment in accordance with the Machinery Directive, 2006/42/EC, has shown that
the risks are mainly of electrical origin and consequently this directive is not applicable. However, the
relevant essential safety requirements of the Machinery Directive are covered by this standard together
with the principal objectives of the Low Voltage Directive.
____________
Endorsement notice
The text of the International Standard IEC 60335-2-108:2008 was approved by CENELEC as a European
Standard with agreed common modification as given below.
COMMON MODIFICATIONS
6 Classification
p Delete the second sentence of the modification.
____________
Bibliography
p Add the following notes to the standards mentioned:
IEC 60335-2-5 NOTE  Harmonized as EN 60335-2-5:2003 (modified).
IEC 60335-2-7 NOTE  Harmonized as EN 60335-2-7:2003 (modified).
ISO 13732-1 NOTE  Harmonized as EN ISO 13732-1:2006 (not modified).
____________

---------------------- Page: 5 ----------------------

SIST EN 60335-2-108:2008
EN 60335-2-108:2008 - 4 -
p Add:
Annex ZC
(normative)

Normative references to international publications
with their corresponding European publications

Publication Year Title EN/HD Year

1) 2)
IEC 60068-2-52 - Environmental testing - EN 60068-2-52 1996
Part 2: Tests - Test Kb: Salt mist, cyclic
(sodium chloride solution)


IEC 60079-15 2005 Electrical apparatus for explosive gas EN 60079-15 2005
atmospheres -
Part 15: Construction, test and marking of
type of protection "n" electrical apparatus


ISO 1817 2005 Rubber, vulcanized - Determination of the - -
effect of liquids


____________


1)
Undated reference.
2)
Valid edition at date of issue.

---------------------- Page: 6 ----------------------

SIST EN 60335-2-108:2008
IEC 60335-2-108
Edition 1.0 2008-01
INTERNATIONAL
STANDARD
NORME
INTERNATIONALE


Household and similar electrical appliances – Safety –
Part 2-108: Particular requirements for electrolysers

Appareils électrodomestiques et analogues – Sécurité –
Partie 2-108: Règles particulières pour les électrolyseurs

INTERNATIONAL
ELECTROTECHNICAL
COMMISSION
COMMISSION
ELECTROTECHNIQUE
PRICE CODE
INTERNATIONALE
P
CODE PRIX
ICS 13.120; 97.060 ISBN 2-8318-9530-8

---------------------- Page: 7 ----------------------

SIST EN 60335-2-108:2008
– 2 – 60335-2-108 © IEC:2008
CONTENTS
FOREWORD.3
INTRODUCTION.5

1 Scope.6
2 Normative references .6
3 Definitions .7
4 General requirement.7
5 General conditions for the tests .7
6 Classification.7
7 Marking and instructions.7
8 Protection against access to live parts.8
9 Starting of motor-operated appliances .8
10 Power input and current .8
11 Heating .8
12 Void.8
13 Leakage current and electric strength at operating temperature.8
14 Transient overvoltages .8
15 Moisture resistance .8
16 Leakage current and electric strength.9
17 Overload protection of transformers and associated circuits .9
18 Endurance.9
19 Abnormal operation .9
20 Stability and mechanical hazards .9
21 Mechanical strength .9
22 Construction .9
23 Internal wiring.10
24 Components .10
25 Supply connection and external flexible cords .10
26 Terminals for external conductors.10
27 Provision for earthing .11
28 Screws and connections .11
29 Clearances, creepage distances and solid insulation .11
30 Resistance to heat and fire.11
31 Resistance to rusting.11
32 Radiation, toxicity and similar hazards.11

Bibliography.15

Annex AA (normative) Ageing test for elastomeric parts.12
Annex BB (informative) Guide for additional requirements to be considered for
inclusion in the end product standards for appliances that incorporate electrolysers .14

---------------------- Page: 8 ----------------------

SIST EN 60335-2-108:2008
60335-2-108 © IEC:2008 – 3 –
INTERNATIONAL ELECTROTECHNICAL COMMISSION
___________

HOUSEHOLD AND SIMILAR ELECTRICAL APPLIANCES –
SAFETY –

Part 2-108: Particular requirements for electrolysers


FOREWORD
1) The International Electrotechnical Commission (IEC) is a worldwide organization for standardization comprising
all national electrotechnical committees (IEC National Committees). The object of IEC is to promote
international co-operation on all questions concerning standardization in the electrical and electronic fields. To
this end and in addition to other activities, IEC publishes International Standards, Technical Specifications,
Technical Reports, Publicly Available Specifications (PAS) and Guides (hereafter referred to as “IEC
Publication(s)”). Their preparation is entrusted to technical committees; any IEC National Committee interested
in the subject dealt with may participate in this preparatory work. International, governmental and non-
governmental organizations liaising with the IEC also participate in this preparation. IEC collaborates closely
with the International Organization for Standardization (ISO) in accordance with conditions determined by
agreement between the two organizations.
2) The formal decisions or agreements of IEC on technical matters express, as nearly as possible, an international
consensus of opinion on the relevant subjects since each technical committee has representation from all
interested IEC National Committees.
3) IEC Publications have the form of recommendations for international use and are accepted by IEC National
Committees in that sense. While all reasonable efforts are made to ensure that the technical content of IEC
Publications is accurate, IEC cannot be held responsible for the way in which they are used or for any
misinterpretation by any end user.
4) In order to promote international uniformity, IEC National Committees undertake to apply IEC Publications
transparently to the maximum extent possible in their national and regional publications. Any divergence
between any IEC Publication and the corresponding national or regional publication shall be clearly indicated in
the latter.
5) IEC provides no marking procedure to indicate its approval and cannot be rendered responsible for any
equipment declared to be in conformity with an IEC Publication.
6) All users should ensure that they have the latest edition of this publication.
7) No liability shall attach to IEC or its directors, employees, servants or agents including individual experts and
members of its technical committees and IEC National Committees for any personal injury, property damage or
other damage of any nature whatsoever, whether direct or indirect, or for costs (including legal fees) and
expenses arising out of the publication, use of, or reliance upon, this IEC Publication or any other IEC
Publications.
8) Attention is drawn to the Normative references cited in this publication. Use of the referenced publications is
indispensable for the correct application of this publication.
9) Attention is drawn to the possibility that some of the elements of this IEC Publication may be the subject of
patent rights. IEC shall not be held responsible for identifying any or all such patent rights.
This part of International Standard IEC 60335 has been prepared by IEC technical committee
61: Safety of household and similar electrical appliances.
It forms the first edition of IEC 60335-2-108.
The text of this part of IEC 60335 is based on the following documents:
FDIS Report on voting
61/3413/FDIS 61/3426/RVD

Full information on the voting for the approval of this standard can be found in the report on
voting indicated in the above table.
This part 2 is to be used in conjunction with the latest edition of IEC 60335-1 and its
amendments. It was established on the basis of the fourth edition (2001) of that standard.

---------------------- Page: 9 ----------------------

SIST EN 60335-2-108:2008
– 4 – 60335-2-108 © IEC:2008
NOTE 1 When “Part 1” is mentioned in this standard, it refers to IEC 60335-1.
This part 2 supplements or modifies the corresponding clauses in IEC 60335-1, so as to
convert that publication into the IEC standard: Safety requirements for electrical electrolysers.
NOTE 2 The following annexes contain provisions suitably modified from other IEC or ISO standards.
Annex AA Aging tests for elastomeric parts ISO 1817
When a particular subclause of Part 1 is not mentioned in this part 2, that subclause applies
as far as is reasonable. When this standard states "addition", "modification" or "replacement",
the relevant text in Part 1 is to be adapted accordingly.
NOTE 3 The following numbering system is used:
– subclauses, tables and figures that are numbered starting from 101 are additional to those in Part 1;
– unless notes are in a new subclause or involve notes in Part 1, they are numbered starting from 101, including
those in a replaced clause or subclause;
– additional annexes are lettered AA, BB, etc.
NOTE 4 The following print types are used:
– requirements: in roman type;
– test specifications: in italic type;
– notes: in small roman type.
Words in bold in the text are defined in Clause 3. When a definition concerns an adjective, the adjective and the
associated noun are also in bold.
A list of all parts of the IEC 60335 series, under the general title: Household and similar
electrical appliances – safety, can be found on the IEC website.
The committee has decided that the contents of this publication will remain unchanged until
the maintenance result date indicated on the IEC web site under "http://webstore.iec.ch" in the
data related to the specific publication. At this date, the publication will be
• reconfirmed;
• withdrawn;
• replaced by a revised edition, or
• amended.
NOTE 5 The attention of National Committees is drawn to the fact that equipment manufacturers and testing
organizations may need a transitional period following publication of a new, amended or revised
...