SIST EN ISO 18363-3:2024
(Main)Animal and vegetable fats and oils - Determination of fatty-acid-bound chloropropanediols (MCPDs) and glycidol by GC/MS - Part 3: Method using acid transesterification and measurement for 2-MCPD, 3-MCPD and glycidol (ISO 18363-3:2024)
Animal and vegetable fats and oils - Determination of fatty-acid-bound chloropropanediols (MCPDs) and glycidol by GC/MS - Part 3: Method using acid transesterification and measurement for 2-MCPD, 3-MCPD and glycidol (ISO 18363-3:2024)
ISO 18363 specifies a procedure for the simultaneous determination of 2-MCPD esters (bound 2-MCPD), 3‐MCPD esters (bound 3‐MCPD) and glycidyl esters (bound glycidol) in a single assay, based on acid catalysed ester cleavage and derivatization of cleaved (free) analytes with phenylboronic acid (PBA) prior to GC/MS analysis.
ISO 18363-3 is applicable to solid and liquid fats and oils. For all three analytes the limit of quantification (LOQ) is 0,1 mg/kg and the limit of detection (LOD) is 0,03 mg/kg.
Tierische und pflanzliche Fette und Öle - Bestimmung von fettsäuregebundenem Chlorpropandiol (MCPD) und Glycidol mittels GC/MS - Teil 3: Verfahren mittels Säureumesterung und Messung für 2-MCPD, 3-MCPD und Glycidol (ISO 18363-3:2024)
Dieses Dokument legt ein Verfahren für die gleichzeitige Bestimmung von 2 MCPD-Estern (gebundenem 2 MCPD), 3 MCPD-Estern (gebundenem 3 MCPD) und Glycidylestern (gebundenem Glycidol) in einer einzigen Prüfung fest, basierend auf einer vor der GC/MS-Analyse erfolgenden säurekatalysierten Esterspaltung und Derivatisierung der abgespaltenen (freien) Analyten mit Phenylboronsäure (en: phenylboronic acid, PBA).
Dieses Dokument ist auf feste und flüssige Fette und Öle anwendbar. Für alle drei Analyten liegt die Quantifizierungsgrenze (LOQ, en: limit of quantification) bei 0,1 mg/kg und die Nachweisgrenze (LOD, en: limit of detection) bei 0,03 mg/kg.
Corps gras d'origines animale et végétale - Détermination des esters de chloropropanediols (MCPD) et d'acides gras et des esters de glycidol et d'acides gras par CPG/SM - Partie 3: Méthode par transestérification acide et mesure du 2-MCPD, du 3-MCPD et du glycidol (ISO 18363-3:2024)
ISO 18363-3 spécifie un mode opératoire permettant la détermination simultanée des esters de 2-MCPD (2-MCPD lié), des esters de 3-MCPD (3-MCPD lié) et des esters de glycidol (glycidol lié) en un seul essai, basé sur le clivage des esters par catalyse acide et la dérivatisation des analytes clivés (libres) à l'acide phénylboronique (PBA) avant analyse par CPG/SM.
ISO 18363-3 est applicable aux corps gras solides et liquides. Pour l'ensemble des trois analytes, la limite de quantification (LOQ) est de 0,1 mg/kg et la limite de détection (LOD) est de 0,03 mg/kg.
Živalske in rastlinske maščobe ter olja - Določevanje maščobno-kislinsko vezanih kloropropandiolov (MCPD) in glicidola z GC/MS - 3. del: Metoda z uporabo kislinske transesterifikacije in meritev 2-MCPD, 3-MCPD in glicidola (ISO 18363-3:2024)
Standard ISO 18363 določa postopek za hkratno določevanje estrov 2-MCPD (vezan 2-MCPD), estrov 3-MCPD (vezan 3-MCPD) in glicidil estrov (vezan glicidol) v enem samem testu, ki temelji na cepljenju estrov, kataliziranih s kislino, in derivatizaciji razcepljenih (prostih) analitov s fenilboronsko kislino (PBA) pred analizo GC/MS.
Standard ISO 18363-3 se uporablja za trdne in tekoče maščobe ter olja. Za vse tri analite je meja kvantifikacije (LOQ) 0,1 mg/kg, meja zaznavanja (LOD) pa 0,03 mg/kg.
General Information
Relations
Standards Content (Sample)
SLOVENSKI STANDARD
01-september-2024
Živalske in rastlinske maščobe ter olja - Določevanje maščobnokislinsko vezanih
kloropropandiolov (MCPD) in glicidola z GC/MS - 3. del: Metoda z uporabo
kislinske transesterifikacije in meritev 2-MCPD, 3-MCPD in glicidola (ISO 18363-
3:2024)
Animal and vegetable fats and oils - Determination of fatty-acid-bound
chloropropanediols (MCPDs) and glycidol by GC/MS - Part 3: Method using acid
transesterification and measurement for 2-MCPD, 3-MCPD and glycidol (ISO 18363-
3:2024)
Tierische und pflanzliche Fette und Öle - Bestimmung von fettsäuregebundenem
Chlorpropandiol (MCPD) und Glycidol mittels GC/MS - Teil 3: Verfahren mittels
Säureumesterung und Messung für 2-MCPD, 3-MCPD und Glycidol (ISO 18363-3:2024)
Corps gras d'origines animale et végétale - Détermination des esters de
chloropropanediols (MCPD) et d'acides gras et des esters de glycidol et d'acides gras
par CPG/SM - Partie 3: Méthode par transestérification acide et mesure du 2-MCPD, du
3-MCPD et du glycidol (ISO 18363-3:2024)
Ta slovenski standard je istoveten z: EN ISO 18363-3:2024
ICS:
67.200.10 Rastlinske in živalske Animal and vegetable fats
maščobe in olja and oils
2003-01.Slovenski inštitut za standardizacijo. Razmnoževanje celote ali delov tega standarda ni dovoljeno.
EN ISO 18363-3
EUROPEAN STANDARD
NORME EUROPÉENNE
July 2024
EUROPÄISCHE NORM
ICS 67.200.10 Supersedes EN ISO 18363-3:2021
English Version
Animal and vegetable fats and oils - Determination of fatty-
acid-bound chloropropanediols (MCPDs) and glycidol by
GC/MS - Part 3: Method using acid transesterification and
measurement for 2-MCPD, 3-MCPD and glycidol (ISO
18363-3:2024)
Corps gras d'origines animale et végétale - Tierische und pflanzliche Fette und Öle - Bestimmung
Détermination des esters de chloropropanediols von fettsäuregebundenem Chlorpropandiol (MCPD)
(MCPD) et d'acides gras et des esters de glycidol et und Glycidol mittels GC/MS - Teil 3: Verfahren mittels
d'acides gras par CPG/SM - Partie 3: Méthode par Säureumesterung und Messung für 2-MCPD, 3-MCPD
transestérification acide et mesure du 2-MCPD, du 3- und Glycidol (ISO 18363-3:2024)
MCPD et du glycidol (ISO 18363-3:2024)
This European Standard was approved by CEN on 5 July 2024.
CEN members are bound to comply with the CEN/CENELEC Internal Regulations which stipulate the conditions for giving this
European Standard the status of a national standard without any alteration. Up-to-date lists and bibliographical references
concerning such national standards may be obtained on application to the CEN-CENELEC Management Centre or to any CEN
member.
This European Standard exists in three official versions (English, French, German). A version in any other language made by
translation under the responsibility of a CEN member into its own language and notified to the CEN-CENELEC Management
Centre has the same status as the official versions.
CEN members are the national standards bodies of Austria, Belgium, Bulgaria, Croatia, Cyprus, Czech Republic, Denmark, Estonia,
Finland, France, Germany, Greece, Hungary, Iceland, Ireland, Italy, Latvia, Lithuania, Luxembourg, Malta, Netherlands, Norway,
Poland, Portugal, Republic of North Macedonia, Romania, Serbia, Slovakia, Slovenia, Spain, Sweden, Switzerland, Türkiye and
United Kingdom.
EUROPEAN COMMITTEE FOR STANDARDIZATION
COMITÉ EUROPÉEN DE NORMALISATION
EUROPÄISCHES KOMITEE FÜR NORMUNG
CEN-CENELEC Management Centre: Rue de la Science 23, B-1040 Brussels
© 2024 CEN All rights of exploitation in any form and by any means reserved Ref. No. EN ISO 18363-3:2024 E
worldwide for CEN national Members.
Contents Page
European foreword . 3
European foreword
This document (EN ISO 18363-3:2024) has been prepared by Technical Committee ISO/TC 34 "Food
products" in collaboration with Technical Committee CEN/TC 307 “Oilseeds, vegetable and animal fats
and oils and their by-products - Methods of sampling and analysis” the secretariat of which is held by
AFNOR.
This European Standard shall be given the status of a national standard, either by publication of an
identical text or by endorsement, at the latest by January 2025, and conflicting national standards shall
be withdrawn at the latest by January 2025.
Attention is drawn to the possibility that some of the elements of this document may be the subject of
patent rights. CEN shall not be held responsible for identifying any or all such patent rights.
This document supersedes EN ISO 18363-3:2021.
Any feedback and questions on this document should be directed to the users’ national standards
body/national committee. A complete listing of these bodies can be found on the CEN website.
According to the CEN-CENELEC Internal Regulations, the national standards organizations of the
following countries are bound to implement this European Standard: Austria, Belgium, Bulgaria,
Croatia, Cyprus, Czech Republic, Denmark, Estonia, Finland, France, Germany, Greece, Hungary, Iceland,
Ireland, Italy, Latvia, Lithuania, Luxembourg, Malta, Netherlands, Norway, Poland, Portugal, Republic of
North Macedonia, Romania, Serbia, Slovakia, Slovenia, Spain, Sweden, Switzerland, Türkiye and the
United Kingdom.
Endorsement notice
The text of ISO 18363-3:2024 has been approved by CEN as EN ISO 18363-3:2024 without any
modification.
International
Standard
ISO 18363-3
Second edition
Animal and vegetable fats and
2024-06
oils — Determination of fatty-acid-
bound chloropropanediols (MCPDs)
and glycidol by GC/MS —
Part 3:
Method using acid
transesterification and
measurement for 2-MCPD, 3-MCPD
and glycidol
Corps gras d'origines animale et végétale — Détermination des
esters de chloropropanediols (MCPD) et d'acides gras et des
esters de glycidol et d'acides gras par CPG/SM —
Partie 3: Méthode par transestérification acide et mesure du
2-MCPD, du 3-MCPD et du glycidol
Reference number
ISO 18363-3:2024(en) © ISO 2024
ISO 18363-3:2024(en)
© ISO 2024
All rights reserved. Unless otherwise specified, or required in the context of its implementation, no part of this publication may
be reproduced or utilized otherwise in any form or by any means, electronic or mechanical, including photocopying, or posting on
the internet or an intranet, without prior written permission. Permission can be requested from either ISO at the address below
or ISO’s member body in the country of the requester.
ISO copyright office
CP 401 • Ch. de Blandonnet 8
CH-1214 Vernier, Geneva
Phone: +41 22 749 01 11
Email: copyright@iso.org
Website: www.iso.org
Published in Switzerland
ii
ISO 18363-3:2024(en)
Contents Page
Foreword .iv
Introduction .v
1 Scope . 1
2 Normative references . 1
3 Terms and definitions . 1
4 Principle . 2
5 Reagents . 2
5.1 Standard and reference compounds .2
5.2 Standard solutions .3
5.2.1 General .3
5.2.2 Stock solutions (1 mg/ml) .3
5.2.3 Working solutions .3
5.3 Other reagents .4
5.4 Reagent solutions .4
6 Apparatus . 5
7 Sample . 5
7.1 Sampling .5
7.2 Preparation of the test sample .5
8 Procedure . 6
8.1 Test sample preparation .6
8.2 Preparation of the calibration curve .7
8.3 Gas chromatography/mass spectrometry references .7
9 Expression of results . 8
9.1 Quantification of 3-MCPD esters .8
9.2 Quantification of 2-MCPD esters .8
9.3 Quantification of glycidyl esters .9
10 Precision . 10
10.1 General .10
10.2 Repeatability .10
10.3 Between-day reproducibility . .10
11 Test report . 10
Annex A (informative) Construction of the calibration curves .11
Annex B (informative) Results of the interlaboratory test .15
Bibliography . 17
...
SLOVENSKI STANDARD
01-september-2024
Živalske in rastlinske maščobe ter olja - Določevanje maščobno-kislinsko vezanih
kloropropandiolov (MCPD) in glicidola z GC/MS - 3. del: Metoda z uporabo
kislinske transesterifikacije in meritev 2-MCPD, 3-MCPD in glicidola (ISO 18363-
3:2024)
Animal and vegetable fats and oils - Determination of fatty-acid-bound
chloropropanediols (MCPDs) and glycidol by GC/MS - Part 3: Method using acid
transesterification and measurement for 2-MCPD, 3-MCPD and glycidol (ISO 18363-
3:2024)
Tierische und pflanzliche Fette und Öle - Bestimmung von fettsäuregebundenem
Chlorpropandiol (MCPD) und Glycidol mittels GC/MS - Teil 3: Verfahren mittels
Säureumesterung und Messung für 2-MCPD, 3-MCPD und Glycidol (ISO 18363-3:2024)
Corps gras d'origines animale et végétale - Détermination des esters de
chloropropanediols (MCPD) et d'acides gras et des esters de glycidol et d'acides gras
par CPG/SM - Partie 3: Méthode par transestérification acide et mesure du 2-MCPD, du
3-MCPD et du glycidol (ISO 18363-3:2024)
Ta slovenski standard je istoveten z: EN ISO 18363-3:2024
ICS:
67.200.10 Rastlinske in živalske Animal and vegetable fats
maščobe in olja and oils
2003-01.Slovenski inštitut za standardizacijo. Razmnoževanje celote ali delov tega standarda ni dovoljeno.
EN ISO 18363-3
EUROPEAN STANDARD
NORME EUROPÉENNE
July 2024
EUROPÄISCHE NORM
ICS 67.200.10 Supersedes EN ISO 18363-3:2021
English Version
Animal and vegetable fats and oils - Determination of fatty-
acid-bound chloropropanediols (MCPDs) and glycidol by
GC/MS - Part 3: Method using acid transesterification and
measurement for 2-MCPD, 3-MCPD and glycidol (ISO
18363-3:2024)
Corps gras d'origines animale et végétale - Tierische und pflanzliche Fette und Öle - Bestimmung
Détermination des esters de chloropropanediols von fettsäuregebundenem Chlorpropandiol (MCPD)
(MCPD) et d'acides gras et des esters de glycidol et und Glycidol mittels GC/MS - Teil 3: Verfahren mittels
d'acides gras par CPG/SM - Partie 3: Méthode par Säureumesterung und Messung für 2-MCPD, 3-MCPD
transestérification acide et mesure du 2-MCPD, du 3- und Glycidol (ISO 18363-3:2024)
MCPD et du glycidol (ISO 18363-3:2024)
This European Standard was approved by CEN on 5 July 2024.
CEN members are bound to comply with the CEN/CENELEC Internal Regulations which stipulate the conditions for giving this
European Standard the status of a national standard without any alteration. Up-to-date lists and bibliographical references
concerning such national standards may be obtained on application to the CEN-CENELEC Management Centre or to any CEN
member.
This European Standard exists in three official versions (English, French, German). A version in any other language made by
translation under the responsibility of a CEN member into its own language and notified to the CEN-CENELEC Management
Centre has the same status as the official versions.
CEN members are the national standards bodies of Austria, Belgium, Bulgaria, Croatia, Cyprus, Czech Republic, Denmark, Estonia,
Finland, France, Germany, Greece, Hungary, Iceland, Ireland, Italy, Latvia, Lithuania, Luxembourg, Malta, Netherlands, Norway,
Poland, Portugal, Republic of North Macedonia, Romania, Serbia, Slovakia, Slovenia, Spain, Sweden, Switzerland, Türkiye and
United Kingdom.
EUROPEAN COMMITTEE FOR STANDARDIZATION
COMITÉ EUROPÉEN DE NORMALISATION
EUROPÄISCHES KOMITEE FÜR NORMUNG
CEN-CENELEC Management Centre: Rue de la Science 23, B-1040 Brussels
© 2024 CEN All rights of exploitation in any form and by any means reserved Ref. No. EN ISO 18363-3:2024 E
worldwide for CEN national Members.
Contents Page
European foreword . 3
European foreword
This document (EN ISO 18363-3:2024) has been prepared by Technical Committee ISO/TC 34 "Food
products" in collaboration with Technical Committee CEN/TC 307 “Oilseeds, vegetable and animal fats
and oils and their by-products - Methods of sampling and analysis” the secretariat of which is held by
AFNOR.
This European Standard shall be given the status of a national standard, either by publication of an
identical text or by endorsement, at the latest by January 2025, and conflicting national standards shall
be withdrawn at the latest by January 2025.
Attention is drawn to the possibility that some of the elements of this document may be the subject of
patent rights. CEN shall not be held responsible for identifying any or all such patent rights.
This document supersedes EN ISO 18363-3:2021.
Any feedback and questions on this document should be directed to the users’ national standards
body/national committee. A complete listing of these bodies can be found on the CEN website.
According to the CEN-CENELEC Internal Regulations, the national standards organizations of the
following countries are bound to implement this European Standard: Austria, Belgium, Bulgaria,
Croatia, Cyprus, Czech Republic, Denmark, Estonia, Finland, France, Germany, Greece, Hungary, Iceland,
Ireland, Italy, Latvia, Lithuania, Luxembourg, Malta, Netherlands, Norway, Poland, Portugal, Republic of
North Macedonia, Romania, Serbia, Slovakia, Slovenia, Spain, Sweden, Switzerland, Türkiye and the
United Kingdom.
Endorsement notice
The text of ISO 18363-3:2024 has been approved by CEN as EN ISO 18363-3:2024 without any
modification.
International
Standard
ISO 18363-3
Second edition
Animal and vegetable fats and
2024-06
oils — Determination of fatty-acid-
bound chloropropanediols (MCPDs)
and glycidol by GC/MS —
Part 3:
Method using acid
transesterification and
measurement for 2-MCPD, 3-MCPD
and glycidol
Corps gras d'origines animale et végétale — Détermination des
esters de chloropropanediols (MCPD) et d'acides gras et des
esters de glycidol et d'acides gras par CPG/SM —
Partie 3: Méthode par transestérification acide et mesure du
2-MCPD, du 3-MCPD et du glycidol
Reference number
ISO 18363-3:2024(en) © ISO 2024
ISO 18363-3:2024(en)
© ISO 2024
All rights reserved. Unless otherwise specified, or required in the context of its implementation, no part of this publication may
be reproduced or utilized otherwise in any form or by any means, electronic or mechanical, including photocopying, or posting on
the internet or an intranet, without prior written permission. Permission can be requested from either ISO at the address below
or ISO’s member body in the country of the requester.
ISO copyright office
CP 401 • Ch. de Blandonnet 8
CH-1214 Vernier, Geneva
Phone: +41 22 749 01 11
Email: copyright@iso.org
Website: www.iso.org
Published in Switzerland
ii
ISO 18363-3:2024(en)
Contents Page
Foreword .iv
Introduction .v
1 Scope . 1
2 Normative references . 1
3 Terms and definitions . 1
4 Principle . 2
5 Reagents . 2
5.1 Standard and reference compounds .2
5.2 Standard solutions .3
5.2.1 General .3
5.2.2 Stock solutions (1 mg/ml) .3
5.2.3 Working solutions .3
5.3 Other reagents .4
5.4 Reagent solutions .4
6 Apparatus . 5
7 Sample . 5
7.1 Sampling .5
7.2 Preparation of the test sample .5
8 Procedure . 6
8.1 Test sample preparation .6
8.2 Preparation of the calibration curve .7
8.3 Gas chromatography/mass spectrometry references .7
9 Expression of results . 8
9.1 Quantification of 3-MCPD esters .8
9.2 Quantification of 2-MCPD esters .8
9.3 Quantification of glycidyl esters .9
10 Precision . 10
10.1 General .10
10.2 Repeatability .10
10.3 Between-day reproducibility . .10
11 Test report . 10
Annex A (informative) Construction of the calibration curves .11
Annex B (informative) Results of the interlaboratory test .15
Bibliography . 17
...
Questions, Comments and Discussion
Ask us and Technical Secretary will try to provide an answer. You can facilitate discussion about the standard in here.